XPO. Ultra low NOx indirect burner

Transcription

1 XPO Ultra low NOx indirect burner -.- E-i -9/ Low temperature burner for use with clean fuel gases Single digit NOx emissions at 0% igh efficiency with low requirements apacities up to 8 Mtu/h with a least : turndown ratio or use in indirect fired solution backed heaters 0 opyright Maxon orporation. ll rights reserved.

2 -.- E-i -9/ Product description MXON XPO burners are low temperature burners for use in liquid backed applications, including: Water back heater ire tube boiler Thermal oil heater irect contact water heater Solution heating/tanks Snow melters XPO burners provide high efficiency operation with low requirements. They are designed for ease of retrofitting into existing liquid backed applications. XPO burners are available in two basic versions: Packaged (P) with integral combustion blower External blower (E) for use with an external combustion source for extended capacities oth packaged (P) and external blower (E) versions include two different choices for blast tube lengths. foot or foot long blast tube is available. last tube length should be selected based on the wall penetration depth or non-liquid cooled portion of fire tube. The packaged (P) version also includes a choice of blower voltage and a choice of /fuel ratio control actuators. MXON requires the use of parallel positioning control systems. or indoor, general purpose installations, use oneywell ontrolink or equivalent system. or outdoor or hazardous duty service installations, use MXON SMRTLINK MRV control systems. XPO burner with oneywell ontrolink XPO burner with MXON SMRTLINK 0 opyright Maxon orporation. ll rights reserved.

3 -.- E-i -9/ vailable XPO ultra low NOx burner sizes Packaged (P) versions Typical burner data uel: natural gas at 60 with 000 tu/ft (st) V - sg = 0.6 [] ombustion : 60 - % O - 50% humidity - sg =.0 [] Stated pressures are indicative. ctual pressures are a function of humidity, altitude, type of fuel and gas quality. XPO P XPO P 5% 0% XPO P XPO P 5% 0% XPO P XPO P 5% 0% XPO P XPO 5 P 5% 0% 5% Maximum burner capacity [] Mtu/h Minimum burner capacity [] Mtu/h Turndown ratio [] :.: :.6: 5:.5: 5:.5: 6.6: 6: 0% [] sg (specific gravity) = relative density to (density = lb/ft (st)) [] Minimum burner capacity will be affected by fuel and applications parameters (heat flux). [] Turndown ratio will vary depending on the application heat flux. Lower heat flux (<8000 tu/in ) will result with lower turndown ratios. [] apacity displayed assumes blower operation on 60z electrical supply. Gross output will be reduced by 7% if operated on 50z. uel and pressure should be reduced by 0% while motor power will reduce 0% with 50z operation. Turndown ratio will be reduced in kind with minimum capacity remaining fixed. External blower (E) versions Typical burner data uel: natural gas at 60 with 000 tu/ft (st) V - sg = 0.6 [] ombustion : 60 - % O - 50% humidity - sg =.0 [] Stated pressures are indicative. ctual pressures are a function of humidity, altitude, type of fuel and gas quality. XPO E XPO 5 E XPO E 5% 0% 5% 0% Maximum burner capacity [] Mtu/h Minimum burner capacity [] Mtu/h Turndown ratio [] 6: 5.6: 5.9: 5.: [] sg (specific gravity) = relative density to (density = lb/ft (st)) [] Minimum burner capacity will be affected by fuel and applications parameters (heat flux). [] Turndown ratio will vary depending on the application heat flux. Lower heat flux (<8000 tu/in ) will result with lower turndown ratios. [] apacity displayed assumes blower operation on 60z electrical supply. Gross output will be reduced by 7% if operated on 50z. uel and pressure should be reduced by 0% while motor power will reduce 0% with 50z operation. Turndown ratio will be reduced in kind with minimum capacity remaining fixed. 0 opyright Maxon orporation. ll rights reserved.

4 -.- E-i -9/ pplications XPO ultra low NOx burners should be used in liquid backed applications, including: Water back heater ire tube boiler Thermal oil heater irect contact water heater Solution heating/tanks Snow melters ) XPO burner ) Mounting flange ) Unit wall ) Liquid solution 5) ire tube 6) urner blast tube 7) Non-cooled fire tube wall 8) ustomer-supplied insulation* *ll non-liquid cooled surfaces must be insulated as shown above. 0 opyright Maxon orporation. ll rights reserved.

5 -.-5 E-i -9/ imensions and weights XPO P (packaged) burners with MXON SMRTLINK actuator E ) -/ NPT main gas inlet ) ir inlet ) urner blast tube ).5 optional oven wall J G XPO P (packaged) burners with general purpose actuator (shown with oneywell ontrolinks actuator) E ) -/ NPT main gas inlet ) ir inlet ) urner blast tube ).5 optional oven wall J imensions in inches unless stated otherwise urner size E G J Weight lbs XPO P XPO P opyright Maxon orporation. ll rights reserved.

6 -.-6 E-i -9/ XPO & P (packaged) burner with MXON SMRTLINK actuator ) -/ NPT main gas inlet ) ir inlet ) urner blast tube ).5 optional oven wall G E XPO & P (packaged) burners with general purpose actuator (shown with oneywell ontrolinks actuator) ) -/ NPT main gas inlet ) ir inlet ) urner blast tube ).5 optional oven wall G imensions in inches unless stated otherwise urner size E G Weight lbs XPO P XPO P XPO P XPO P opyright Maxon orporation. ll rights reserved.

7 -.-7 E-i -9/ XPO & 5 P (packaged) burner with MXON SMRTLINK actuator ) NPT main gas inlet ) ir inlet ) urner blast tube ).5 optional oven wall E G XPO & 5 P (packaged) burners with general purpose actuator (shown with oneywell ontrolinks actuator) ) NPT main gas inlet ) ir inlet ) urner blast tube ).5 optional oven wall E G imensions in inches unless stated otherwise urner size E G Weight lbs XPO P XPO 5 P opyright Maxon orporation. ll rights reserved.

8 -.-8 E-i -9/ XPO E (external blower) burner ) -/ NPT gas inlet ) ombustion inlet ) urner blast tube ).5 optional oven wall E imensions in inches unless specified otherwise urner size E Weight lbs XPO E XPO E XPO 5 E (external blower) burner ) NPT gas inlet ) ombustion inlet ) urner blast tube ).5 optional oven wall E imensions in inches unless specified otherwise urner size E Weight lbs XPO 5 E Typical emissions XPO burner will achieve ultra low NOx emissions while operating at 0% level. Exact emissions performance may vary in your application. ontact MXON for information on installation specific estimates or guarantees. No guarantee of emissions is intended or implied without specific written guarantee from MXON. Read Specifications of XPO burners for complete information on XPO burners. 0 opyright Maxon orporation. ll rights reserved.