REGISTRATION NO: G-LEAR CONSTRUCTOR'S NO: 35A-265

Transcription

1 AIRWORTHINESS APPROVAL NOTE NO: Issue 3 APPLICANT: AIRCRAFT TYPE: Avionics Mobile Services Ltd. Learjet 35A REGISTRATION NO: G-LEAR CONSTRUCTOR'S NO: 35A-265 OPERATOR: INSTALLER: DESIGN ORGANISATION: CERTIFICATE CATEGORY: MODIFICATION NO: MODIFICATION TITLE Northern Executive Aviation Avionics Mobile Services Ltd. Avionics Mobile Services Ltd. Transport Category (Passenger) AM1410/AM1411 Installation of Honeywell Mk. Vlll EGPWS and Honeywell Flight Data Recorder Generally in Accordance With Bombardier STC 1. INTRODUCTION Avionics Mobile Services Limited modifications AM1410 and AM1411 introduce EGPWS and DFDR respectively, and are based on the Bombardier STC s ST00423DE-D (EGPWS) ST00351DE-D (DFDR). The installation of the Honeywell Mk. Vlll EGPWS to a Bombardier Lear Jet 35A provides terrain information, displayed on the combined radar and EGPWS KMD 850 indicator, positioned in the centre instrument panel. A Honeywell Flight Data recorder is also installed. The Radio Altimeter and Radar systems are upgraded to accommodate changes introduced by these modifications. Issue 2 raised to correct aircraft type designation. Issue 3 raised to correct CAA Approval number of EGPWS equipment in paragraph 4.2 and MODIFICATION DEFINITION The MkVIII EGPWS based on Bombardier STC ST00423DE-D provides ground proximity alert/warnings, advisory altitude and bank angle callout / warnings. The specific callout menus and outputs functions are configurable using a lap top computer. The information is displayed to the crew on the KMD 850 installed in the centre instrument panel. The system provides protection against the following. I) Excessive Decent Rate II) Excessive Terrain Closure Rate III) Excessive altitude Loss after Take Off or missed approach procedure IV) Unsafe Terrain Clearance V) Excessive Deviation Below Glideslope VI) Excessive bank angle. VII) Incorrect landing configuration

2 The EGPWS processor and mounting tray are housed on a shelf in the nose equipment bay. The Terrain display (RADAR indicator KMD 850) is located in the centre instrument panel. Annunciators are added to the P1 s and P2 s instrument panel giving indication for PULL UP and GPWS cautions and warnings. These annunciator s are configured to Honeywell s Lamp Format 2. A further three EGPWS annunciators are installed on the centre instrument panel indicating: a) FLAP O/RIDE (AMBER) b) GPWS INOP/TERR FAIL (AMBER/AMBER) c) TERR INHIBIT (AMBER) A dedicated cockpit speaker is installed for aural warnings. Audio is also supplied to unswitched inputs on the P1 s and P2 s audio panel. Air data is obtained from the newly installed I S&S Air Data System No.2 ADDU. This installation is covered by a Bombardier STC and approved by AAN Heading data is obtained from the existing JET secondary directional Gyro auxiliary output The Roll data is provided to the EGPWS from an existing JET secondary vertical gyro Radio Altitude data is provided from the ALT 55B Glide slope data is provided from No. 2 NAV RX VIR 30 Flap position data is provided from No. 2 Stall warning Flap Down Micro Switch. Gear position data from the Nose Down Lock Micro Switch. Geometric Altitude is calculated within the EGPWC. A Cockpit display RADAR Indicator (KMD850) is housed in the centre instrument panel A description of the modification is contained in Avionics Mobile Project Certification Plan, Document No. CP/1410. The GPS information is received from an existing GPS antenna via a Honeywell Antenna splitter to the internal GPS receiver within the EGPWS processor. Note the B-RNAV information is supplied from the other GPS system. Avionics Mobile Services limited have produced a Safety Assessment for Modification AM1410 on the Bombardier Lear Jet 35A. Avionics Mobile modification Document AM1410 installation of Honeywell Mk. Vlll Enhanced Ground Proximity Warning System EGPWS refers. The Radar Altimeter system is to be upgraded from an ALT50 to an ALT55B with a Flight Manual supplement covering this. The RADAR system has been upgrade to an ART 2100 making it compatible with the KMD 850 The Flight Data Recorder installation is based on Bombardier STC ST00351DE-D and covers the required five parameters plus (JAR-OPS 1.715). The FDR is to be housed in redundant aircraft racking in the rear of the aircraft and this is stressed to 10G. Provision for recording of EGPWS parameters is provided and future provision for recording of ACAS parameters is accommodated by laying in the wiring and capping. A DFDR Fail annunciator is installed on the centre instrument panel adjacent to the EGPWS annunciators. The parameters to be recorded are listed below. 2

3 Parameters: - 1) Elapsed Time DFDR 2) Altitude I S&S Aircraft Interface Unit 3) Indicated Air Speed I S&S Aircraft Interface Unit 4) Heading Bootstrapped to the secondary RMI 5) Acceleration Dedicated Accelerometer 6) Pitch and Roll Secondary attitude Gyro (JET ) interfaced at No.2 ADI 7) Radio Keying Audio Panel 8) EGPWS EGPWS Discrete. 9) TCAS provision for. These modifications install the following equipment: AM Installation of EGPWS Honeywell MkVlll EGPWS Honeywell KMD Honeywell KAC Collins ALT 55 B ART 2100 RADAR AM Installation of DFDR Honeywell FDR Accelerometer In addition, a number of annunciators and switches are added to the flight deck Modification AM1410 also removes the following equipment: Collins RAD ALT 50A Bendix RDR APPROVAL PROCEDURES The Equipment is installed in accordance with the Civil Aviation Specification No. 14, titled Ground Proximity Warning System and JAA TGL 12 Flight recorder TSO C124A/ED55, JAR-OPS 1.715, Civil Aviation Specification No. 10, titled Flight Recorder Systems. 4 BASIS OF CERTIFICATION 4.1 CERTIFICATION BASIS FOR THE MODIFICATION The original Type certificate Data Sheet for the Bombardier Lear Jet 35A is as specified in CAA Type Certificate Data Sheet No: FA23 Issue 1. EUROCAE Spec ED-55 Amendment 1, May JAR-OPS Flight Data Recorders 3 and JAR-OPS is applicable. The following JAR 25 requirements are applicable for this modification: JAR , 25X899, , , , 25,1321, , , , , and

4 4.2 CAA DESIGN REQUIREMENTS FOR CERTIFICATION OF AIRWORTHINESS Civil Aviation Specification No. 14, titled Ground Proximity Warning System and JAA TGL 12 CAA Specification No. 10A is applicable to the approval of this modification, the requirements of which have been met within EUROCAE ED-55. Any installed equipment for which the ANO requires approval must be approved by the CAA. Honeywell MkVlll EGPWS Honeywell KMD Honeywell KAC Collins ALT 55 ART 2100 RADAR Honeywell FDR Accelerometer CAA Approval VC01179 CAA Approval VC00292 CAA Approval VC01077 CAA Approval AR01345 CAA Approval AR ENVIRONMENTAL REQUIREMENTS This modification must not alter the Bombardier Lear Jet 35A noise or emissions requirements 4.4 DESIGN REQUIREMENTS ASSOCIATED WITH OPERATIONAL APPROVALS JAR OPS and JAR-OPS Flight Data Recorders 3 are applicable to this modification. 5 COMPLIANCE WITH THE BASIS OF CERTIFICATION 5.1 COMPLIANCE WITH THE CERTIFICATION BASIS FOR THE MODIFICATION The original Type certificate Data Sheet for the Bombardier Lear Jet 35A is FA23 Issue 1 is not affected by the introduction of Avionics Mobile modification s AM 1410 and AM This modification complies with the requirements of JAR , 25X899, , , , 25,1321, , , , , and All drawings (where applicable) on this modification have been approved for structural integrity. Avionics Mobile have produced the following documents which establish compliance with the requirements: a) Project Certification Plan Doc No: CP/1410 b) TAWS Compliance Statement Doc No: CS/1410 c) Safety & Technical Statement Doc No: TS/1410 d) B-Conditions Flight Assessment Doc No: FA/1410 e) Safety Assessment Record (TAWS) Doc No: SA/1410 f) Safety Assessment Record (FDR) Doc No: SA/1411 g) Ground Test Results Record (TAWS) Doc No: GT/1410 h) Post Installation Checkout Proc. (FDR) Doc No. Q033-1 i) Flight Eval. & Results Record (TAWS) Doc No: FE/1410 j) Flight Test Procedure (FDR) Doc No: Q034-1 k) Supplementary Requirements Record (TAWS & FDR) Doc No: SR/1410 l) Parameter Calibration Data Report for AM1411 m) Flight Manual Supplement (TAWS) Doc No: FM/1410/01 n) Flight Manual Supplement (Wx\Radar & KMD 850) Doc No: FM/1410/02 o) Flight Manual Supplement (Radar Alt) Doc No: FM/1410/03 p) Flight Manual Supplement (FDR) Doc No: FM/1411/01 q) Modification Document (Mod Pack TAWS) Doc No: AM 1410 r) Modification Document (Mod Pack FDR) Doc No: AM COMPLIANCE WITH DESIGN REQUIREMENTS FOR CERTIFICATE OF AIRWORTHINESS 4

5 The Equipment is installed in accordance with the Civil Aviation Specification No. 14, titled Ground Proximity Warning System and JAA TGL 12. Flight Recorder TSO C124A/ED55, JAR-OPS 1.715, Civil Aviation Specification No COMPLIANCE WITH ENVIRONMENTAL REQUIREMENTS This modification is assessed as having no adverse effect on the aircraft noise, and the status of the aircraft relative to the noise legislation is unaffected. The existing noise certificate, if any remains valid. 5.4 COMPLIANCE WITH DESIGN REQUIREMENTS ASSOCIATED WITH OPERATIONAL APPROVALS Avionics Mobile have produced modification AM 1410 which establishes compliance with JAR-OPS and AM 1411 which establishes compliance with JAR-OPS Flight Data Recorders 3. Note: Compliance has been established with the design requirements, which are a pre-requisite to approval of the associated operation. This finding of compliance with the design requirements does not signify that any operational approval has been granted. 5.5 REQUIRED AMENDMENTS TO MANUALS AND OTHER DOCUMENTS INCLUDING PLACARDS The following manuals, as stated in Avionics Mobile modification (Mod Pack) AM 1410 and AM 1411 are affected by the installation of this modification: a. Flight Manual b. Illustrated Parts Catalogue. c. Maintenance Manual. d. Weight and Balance Schedule. e. Electrical Load Analysis. f. Maintenance Schedule. g. Wiring Diagram. The KMD 850 display is to be placarded NOT TO BE USED AS A MEANS OF PRIMARY NAVIGATION as detailed on drawing, AV Mob AM1410/03 The EGPWS on FLAP O/RIDE annunciator PUSH AND HOLD placard adjacent to the annunciator as detailed on drawing, AV Mob AM1410/ FLIGHT MANUAL SUPPLEMENT Avionics Mobile Services Limited Flight Manual Supplements reference FM1410/01(EGPWS), FM1410/02(KMD850), FM1410/03(RAD ALT) and AM1411/01 (FDR) have been approved for Bombardier Lear Jet 35A Flight Manual. These Flight Manual Supplements must be included in the Operators approved Flight Manual for the aircraft. 5.7 EQUIPMENT APPROVAL Honeywell MkVlll EGPWS Honeywell KMD Honeywell KAC Collins ALT 55 ART 2100 RADAR Honeywell FDR Accelerometer CAA Approval VC01179 CAA Approval VC00292 CAA Approval VC01077 CAA Approval AR01345 CAA Approval AR

6 6 CONDITIONS AFFECTING THIS APPROVAL Compatibility: The installer must verify the compatibility of this modification with other previous approved modifications, installed on the particular aircraft. Where the potential for interaction between modifications exists, the advice of the CAA shall be sought. 7 CONTINUED AIRWORTHINESS The influence of the modification on Airworthiness Directive, Service Bulletin eligibility and other data must be considered and the publications monitored accordingly. The maintenance schedule for the aircraft should include reference to this material additional to the original design 8 SURVEY The installation of the above modification has been inspected by the CAA and found to be satisfactory. 9 AUTHORISATION OF RELEASE TO SERVICE In addition to the actions required by the procedures for release to service following maintenance or modification, the following actions must be completed prior to signing the Certificate of Release to Service: a. All actions and ground test procedures specified in the modification must be completed satisfactorily. b. It must be verified that the documents or amendments to documents, and the placards defined under Section 5.5 above are as specified, including any changes specified under Section 8 above. c The functional flight test must be successfully completed. Any unexpected events or difficulties encountered during the flight must be reported to CAA Flight Department as soon as practicable. 10 APPROVAL Subject to the conditions of section of section 6 above and 11, AVIONICS MOBILE SERVICES LTD. Modification No s. AM1410 and AM1411 are approved for the embodiment on any Bombardier Lear Jet 35A aircraft certificated in the Transport Category, provided that it conforms with the contents of this AAN, and is operated in accordance with the Flight Manual. K Hallworth... For the Civil Aviation Authority Date 4 April