Universal 10 x 27 Canopy C81027PC Size: 10 8 x 27 x 6 8 (side) x 9 9 (center) With 10 Legs, Frame, and Cover Powell & Powell Supply Company Distributed by: 1730 Five Points Lane Fuquay-Varina, North Carolina 27526, USA 1-800-800-6296 www.kingcanopy.com
2 PARTS ALL PIPE IS 1 3/8 INCH 6 6 Pipe Quantity 22 5 8 Pipe Quantity 10 3 Way Corner Quantity 6 4 Way Corner Quantity 9 Elastic Ball Straps Quantity 50 Curtain Clips Quantity 4 Cover Quantity 1 1 Year Limited Warranty for Covers Foot Pads Quantity 10 (Note: Foot Pads are not for anchoring)
3 FRAME ASSEMBLY 1. Place all corners and pipe on the ground. (All pipes are 1 3/8 inch dia.) The 78 pipe form the length of frame and the 68 are for the roof rafters. Remaining 78 pipes are for the legs (All pipes is 1 3/8 inch) 2. Connect pipe together starting with the center frame. Then assemble each side.
4 ATTACHING COVER WITH BALL STRAPS 3. Unfold the cover putting the grommets on the bottom. This allows the flap to cover outside edge of the frame. Once unfolded, place the cover over the frame. Begin attaching the cover with the elastic ball straps (Further ball strap installation instructions on the following page). 1. Start by attaching two straps at each of the four corners. 2. Continue attaching straps from left to right down the sides of the canopy. 3. Finally, attach straps from front to back until all straps are secure.
5 ATTACHING BALL STRAPS 4. First, insert the cord of the elastic ball strap underneath the cover and through the grommet. Then pull cord until ball stops. Wrap the cord around the pole and then around the ball. This will hide the ball under the cover and create a neater look. TO GET A TIGHTER FIT ON CANOPY COVER The ball straps are long enough to accommodate various cover lengths. If your straps are too long for a tight fit, making an additional knot in the strap cord can shorten them. 1. Slide the ball upwards to reveal the tied knot. 2. Tie a new knot above the old one. The length taken up here determines how short the strap becomes. 3. Slip the ball down over the new knot. 4. Cut off the excess cord.
6 PUTTING LEGS ON CANOPY FRAME 5. 1. First, insert both middle legs on one side, and then insert the end legs. Repeat on the other side. Once the legs are inserted, your canopy is a kite waiting to take off until you install the canopy anchors! See the following page for canopy anchor installation. INSTALLATION OF CURTAIN CLIPS 6. Curtain clips are designed to hold the flaps of the cover down in light windy conditions. 1. Slip on clip onto each of the corner legs. 2. To secure the clips on the corner legs use the drawstring sewn into each end of the cover. Adjust the drawstring evenly on each side of the canopy by pulling the drawstrings on each end of the cover at the same time. Insert the ball on the drawstring into the slot of the curtain clip. Pull the clip down until tight. Pressure from the drawstring will cause the clip to wedge onto the pipe. 3. Grommets are located on side flaps above each leg. Put elastic ball strap through grommet then insert the ball into the curtain clip. 4. Curtain clips may have to be re-tightened occasionally due to strong wind gusts.
7 INSTALLING CANOPY ANCHORS (Anchor kit is NOT included with canopy) This canopy is designed for use as a temporary structure. After construction, the canopy must be securely anchored to prevent damage against winds. Canopies make excellent kites. If the canopy legs are not anchored, severe winds will cause the frame to flex and unanchored legs will fall, collapsing the canopy. If sever winds are expected, please remove the cover from the frame to prevent damage. The best way to anchor your canopy is with screw-in ground anchors and cable/rope attached to each leg. You should tie the cable/rope around the slip in fitting on the top of each leg. Mobile home anchors will work. If you intend to secure your canopy more permanently, you may want to use a heavier cable, such as 3/16 aircraft cable. If our canopy rests on concrete, we offer Canopy Feet. These are made of galvanized steel tubing with a galvanized plate welded on the bottom. There are holes drilled into the plate for easier bolting to the concrete. These are available in 48 lengths. When screw in anchors and cable/rope is not used, all legs need to be bolted into fittings at the tops of each leg. To order Canopy Feet for your canopy from our company call 1-800-800-6296 and ask for the sales department. 1. Measure out from each leg at least 36. 2. Screw anchor into the ground. Leave about 3 inches between the ground and the eye on each anchor. 3. Tie cable/rope around fitting on the top of each leg. 4. Tie other end of cable/rope to the anchor and pull tight. 5. Screw anchor until the bottom of the eye is flush with the ground. This will make the cable or rope tighter. 6. Check and tighten rope frequently. 913-980-6110
8 IMPORTANT: PLEASE READ CAREFULLY Because Powell & Powell Supply Co. has no control over wind or snow, we are in no way responsible for damage caused by the canopy or to the canopy. We suggest you contact your insurance carrier for notification just as you would for any other outside structure. OTHER CAUTIONS Do not cook underneath canopy. Do not ignite fireworks underneath canopy. Do not bleach cover to clean Do not dry clean Do not wash in washing machine or dry in dryer. *Hand wash with mild soap and water. Remove cover before a storm. Keep snow brushed off cover if it is snowing. Do not allow rainwater to gather on top of cover. This is a temporary structure and is not recommended as a permanent structure.
9 Product Information Defective Parts We try our best to minimize any defective parts that are shipped with our products. Unfortunately, we cannot catch all defects. Within 30 days from the time you purchase any of our products, we will replace free of charge any part which is deemed defective with the proper receipt. Your replacements will be shipped to you by UPS Ground, at no charge. Damages from improper anchoring, strong winds, snow, or ice are not considered defects. Next-Day replacements sent will require payment of shipping charges. Improper Anchoring, Strong Winds, Snow or Ice Powell & Powell Supply does not guarantee these canopies in snow or ice under any circumstances. Canopies are designed to protect against damages caused by the sun, tree sap, birds, etc. They are not designed to hold the roof loads that accompany snow, ice, or heavy rains. If your canopy is not anchored securely, it will fly away. Canopies make excellent kites. If your canopy takes flight, we will not send free replacements. Anchoring is your responsibility. We offer several types of anchoring kits from temporary to semi-permanent. If you know that a strong weather front is coming remove the cover. The cover is designed to be quickly and easily removed. Weather related damage is not considered as defects. Covers All covers we sell are equipped with a limited warranty. 1 Year Limited Warranty for Covers. Within 6 months of purchase, we will replace the cover for any reason deemed to be a manufacture s defect. After 6 months, you may purchase a replacement cover at a pro-rated price as specified below. In order to receive a discount or free replacement you may be asked to return the defective cover to our warehouse for inspection before we will send a replacement. You must, in all cases provide a copy of your receipt showing the date of purchase, model, and price. 7 Months 83% Discount 8 Months 66% Discount 9 Months 50% Discount 10 Months 33% Discount 11 Months 16% Discount 12 Months No Discount Certain regions of the country are extremely hard on covers of any kind. If you live in these areas (such as Florida, Texas, New Mexico, Arizona, Nevada or High Altitudes) you probably already know how the sun can make life difficult. Chances are you may have to use the charts above. Normal wear and tear is not covered and should be expected. In order to receive a discount or free replacement you may be asked to return the defective cover to our warehouse for inspection before we will send a replacement. You must, in all cases provide a copy of your receipt showing the date of purchase, model, and price. For replacement parts or any other problems 8:00am 5:00pm EST Monday-Friday 1-800-800-6296 Toll Free or 919-552-2977 Fax 919-552-5069 We will send any parts via UPS Ground or US Mail only. Additional covers are available directly from out factory. Our covers are treated to withstand ultraviolet rays from the sun for a longer period than covers normally available from hardware stores and home centers.