CARAVA & MOTORHOME SERVICIG Mr A Other 12 Camping Lane Happyland Membership o: 1570 Methven 29 Lon Pendyffryn LLanddulas orth Wales LL22 8JQ 01492512612 07800565449 cms-northwales@hotmail.co.uk www.cms-northwales.co.uk Service Record 100343 CriS umber Make of Van Model Location of Van Location Post Code CARAVA SERVICE SCHEDULE AD ISPECTIO RECORD Year 2014 XXXXXXXXXXXX-CCCCCCCCC BAILEY UICOR BARCELOA As Above XXXXXXX Service Required Full Service SERVICE SHEETS LAYOUT, SCHEDULE AD WCS LOGO COPYRIGHT OF WCS Work Complete Kevin Williams Date Completed 05/12/2015 Any gas appliance identified as OT SAFE TO USE must OT BE USED until repaired or replaced It is STROGLY ADVISED that customers recheck the tightness of wheel nuts before all journeys and again after the first 30 miles to prevent possible loss of road wheel AcoP LPG Gas reg no 43744 Approved warranty, service agent and installer
GAS SAFETY ISPECTIO RECORD PROPAE BUTAE /A OPERATIG PRESSURE30 MB GAS HOSE DATE 2014 LOCK UP PRESSURE 45 mb LET BY TEST TIGHTESS TEST 1 TIGHTESS TEST 2 PASS 30 30 mb mb PRESSURE LOSS 0 mb SAFE TO USE YES REGULATOR VETILATIO GAS COMPARTMET CYLIDER SECURITY HOSE AD PIG TAILS LPG STICKER X X Gas safety check in accordance with BS5482-1:2005, LPGA's TM83 and IGE-UP-1B edition 3 (with amendments 2012) also CC memorandum o 83 2005 APPLIACE FUCTIO CHECKS MAKE MODEL OPERATIG PRESSURE FLUE TYPE FLUE FLUE TERMIATIO CODITIO FLAME CHECK SAFETY DEVICE SAFE TO USE COER FRIDGE WATER HEATER FIRE THETFORD 30 MB FL /A /A PASS PASS YES DOMETIC 30 MB RS PASS PASS PASS PASS YES TRUMA 30 MB RS PASS PASS PASS PASS YES TRUMA 30 MB RS PASS PASS PASS PASS YES F/L = flueless R/S = room sealed V/C = visual check /C = not checked /A = not applicable = Checked, no fault found. * = Action taken / Advice. X = Defect, Fault found requires Attention /Action Safe Co levels CARBO MOOXIDE BACKGROUD LIVIG AREA READIG Safe Co levels DEFECTS / REMEDIAL ACTIO / OTES 1. o securing strap fitted to Gas Bottle. Recommend a new strap is fitted. 2. o LPG Sticker on gas compartment. ew sticker applied. GAS SYSTEMS SAFE TO USE Customer present or advised YES YES Kevin Williams Date 05/12/2015 Any gas appliance identified as OT SAFE TO USE must OT BE USED until repaired or replaced
LIVIG / HABITATIO / ELECTRICAL / WATER CHECKED FURITURE AD FIXIGS WIDOWS SEALS AD BLIDS ROOF VETS / SKY LIGHTS FIXED VETILATIO ICLUDIG VERMI GUARDS MAI DOOR AD FLY SCREE / BLID EXTERIOR LOCKS CHECKED AD OILED TOILET CASSETTE SEAL CHECKED AD LUBRICATED SME ALARM AD Co ALARM CHECK FIRE EXTIGUISHER AD BLAKET GRAB HADLE CODITIO AD SECURITY FLOOR CODITIO AWIG RAILS, ROOF AD BODYWORK WATER TAK AD FITTIGS WATER FILTER CHAGE WATER SYSTEM AD TAPS 240 VOLT SUPPLY AD RCD TEST (not certified) 240 VOLT APPLIACES AD SOCKETS (not certified) 240 VOLT EARTH BODIG (not certified) 12 VOLT WATER PUMP 12 VOLT AD MAUAL TOILET PUMP 12 VOLT LIGHTS 12 VOLT SYSTEMS BATTERY CODITIO BATTERY CHARGIG RATE 13.7 BATTERY DISCHARGE TEST AIR CODITIOIG Volts * /A * /A Comments / Recommendations 1. Smoke alarm missing its battery. ew battery installed, smoke alarm now working. 2. ew water filter required. ew filter supplied and installed after obtaining agreement with customer. = Checked, no fault found. * = Action taken / Advice, see comments box for details. X = Defect, Fault found requires Attention /Action
DAMP IGRESS SURVEY FROT AROUD WIDOWS ROOF LEVEL CHECKED REAR AROUD WIDOWS ROOF LEVEL CHECKED FLOOR LEVEL EARSIDE OFFSIDE FLOOR LEVEL EARSIDE OFFSIDE OFFSIDE AROUD WIDOWS EARSIDE AROUD WIDOWS ROOF LEVEL ROOF LEVEL FLOOR LEVEL FLOOR LEVEL FROT FROT REAR REAR AROUD DOOR SHOWER AREA FROT SKYLIGHT TOILET AREA REAR SKYLIGHT BATHROOM SIK KITCHE SIK BATHROOM SKYLIGHT KITCHE SKYLIGHT 8 AVERAGE BACKGROUD LIVIG AREA DAMP READIG 8 % Comments / Recommendations 1. o damp found, all readings within ormal range between 1-15%. See damp readings on next page Damp readings = 1-15% ormal. M = 15-20% Monitor. I = 20% and above Water Ingress. 30% and above Structural damage may be occurring and deterioration inevitable. Due to construction, fitted appliances and stored items some areas can only be visually inspected for damp ingress
Damp drawings are not to scale and are for illustration purposes only Due to construction, appliances and stored items a visual inspection of these areas might be performed if probing or scanning is not possible due to limited access
CHASSIS ISPECTIO CHECKED 7 / 13 PI PLUG COECTOR TO CAR ROAD LIGHTS AD REFLECTORS CHARGIG, FRIDGE AD ITERAL LIGHTS ELECTROIC STABILITY SYSTEM OSE WEIGHT CHECK COUPLIG HEAD GREASED AD CHECKED COUPLIG HEAD GAITER CHECKED BALL ACTIG STABILISER CHECKED JOCKEY WHEEL GREASED AD CHECKED BRAKE AWAY CABLE CODITIO HAD BRAKE OPERATIO GREASED AD CHECKED BRAKE ROD AD CABLES CODITIO CHASSIS CODITIO CHASSIS BOLTS AD FIXIGS CORER STEADIES GREASED AD CHECKED SUSPESIO AD AXLE CODITIO HUB ASSEMBLY GREASED AD CHECKED BRAKE ASSEMBLY GREASED AD CHECKED X BRAKE PAD / SHOE CODITIO Thickness 4mm ROAD TYRE CODITIO AD AGE Tyre Date 2013 Depth MM Pressure PSI Front Rear Spare 7 65 7 65 8 65 SPARE TYRE CODITIO WHEEL UTS CHECKED AD TORQUED ut Torque 130nm alloy Comments / Recommendations 1. Ball acting stabiliser friction pads worn passed there limit. ew friction pads required. Caravan should not be taken on the highway until new friction pads are installed. Customer informed. I confirm that all wheel nuts and hub nuts have been TORQUED correctly and rechecked for tightness Work Complete Kevin Williams Date Completed 05/12/2015 It is STROGLY ADVISED that customers recheck the tightness of wheel nuts before all journeys and again after the first 30 miles to prevent possible loss of road wheel
IMPORTAT IFORMATIO and ADVICE = Checked, no fault found. * = Action taken / Advice, see comments box for details. X = Defect, Fault found requires Attention /Action Damp readings = 1-15% ormal. M = 15-20% Monitor. I = 20% and above Water Ingress. 30% and above Structural damage may be occurring and deterioration inevitable Damp drawings are not to scale and are for illustration purposes only Due to construction, appliances and stored items a visual inspection of these areas might be performed if probing or scanning is not possible due to limited access Any gas appliance identified as OT SAFE TO USE must OT BE USED until repaired or r e p l a c e d CARBO MOOXIDE. Do not use any disposable barbecue or portable gas appliances within the caravan, motorhome or awning. As part of a gas safety check, background Carbon Monoxide is monitored and recorded on the service report. The monitoring is performed with all room sealed gas appliances running. If you suspect a gas appliance has developed a fault immediately turn off appliance, close the appliance isolation valve and close the gas bottle control valve. Ventilate the caravan / motor home by opening windows, roof lights a n d d o o r s. D O O T r e - l i g h t o r u s e s u s p e c t e d f a u l t y a p p l i a n c e. As soon as possible contact CMS on 01492512612/07800565449 for assistance and advice. Please leave a message on the answer phone clearly stating your name, contact phone number, location and nature of gas e m e r g e n c y. It is STROGLY ADVISED that customers recheck the tightness of wheel nuts before all journeys and again after t h e f i r s t 3 0 m i l e s t o p r e v e n t p o s s i b l e l o s s o f r o a d w h e e l. Tyre pressures should be checked before all journeys. Tyre pressures can be found in your owners manual. Whilst every effort has been made by CMS in the service / inspection of your Caravan / Motor home to ensure you have a trouble free year, the service / inspection is only valid on the day of the service and does not imply any warranty, guarantee, or life expectancy of the caravan / motor home or appliances and fittings. Damp ingress inspection and report is done to the best of my ability, CMS will not be held liable for any omissions or s u b s e q u e n t f i n d i n g s n o t i d e n t i f i e d i n t h e d a m p i n g r e s s r e p o r t. Caravans and Motorhomes under manufactures warranty. It is not the responsibility of CMS to seek approvel from the dealer or manufacturer of your caravan or motorhome before undertaking any service or repairs. CMS will always advise the customer to satisfy themselves that their warranty will not be effected by any work u n d e r t a k e n b y C M S a n d f o r t h e m t o c o n t a c t t h e i r d e a l e r f o r a d v i c e. T h e a i m o f C a r avan & M o t o r h o m e S e r v i c e s i s y o u r t o t a l s a t i s f a c t i o n. For additional advice and information visit our web site at: www.cms-northwales.co.uk If you require any further advice or assistance please contact Kevin on 01492512612 / 07800565449 (24 hr answer machine) SERVICE SHEETS LAYOUT, SCHEDULE AD WCS LOGO COPYRIGHT OF WCS
CARAVA & MOTORHOME SERVICIG Dear Mr A Other Reference number 100343 Thank you for choosing CMS for your servicing. If you have any questions about the service schedule or report please contact me on 01492512612 and I will help with your enquiry. Your next service will be due on 01/12/2016 We will contact you about one month before this date to see if it's convenient. If you would like to be contacted by email please send an email to cms-northwales@hotmail.co.uk and quote your reference number Thanking you again for your custom. Kevin Williams CMS can offer a range of services, as well as maintenance and repair, from a comprehensively stocked service vehicle. Services: Touring Caravan Service and repairs Motor home Habitation Service and repairs Part Services i.e. gas safety check Caravan Motor movers supplied and fitted Sanitation of water systems Alde central heating systems Shower tray repairs Stockists of: Gas Regulators, Leisure Batteries, Water Pumps, Water Filters, Taps. Etc I will come to you at home, on site, or in storage logon to www.approvedworkshops.co.uk and complete the online Customer Satisfaction Survey www.cms-northwales.co.uk AcoP LPG Gas reg no 43744 Approved warranty, service agent and installer