Adapters New to Eaton Weatherhead How to Order

Transcription

1 PPITIO T dapters ew to Eaton Weatherhead How to Order OW & EIU ew Eaton dapter Part umbers dapter part numbers consist of a base number followed by a size designation. If the part number contains a T character between the base number and size designator, the first size designator signifies the tube size. Example: FF1852 T S How to order FOR-SE dapters and Tube Fittings FOR-SE tube fitting body with O-ring, locknut and washer, where applicable. Example: FF1852T S HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES Base part number T character Tube size Pipe or port size aterial designation suffix (carbon steel) If the part number does not contain a T character between the base number and the size description, the first size designation signifies the port size. Example: Base part number Pipe or port size Tube size aterial designation suffix (carbon steel) How to Order ew Eaton dapters S dapters are ordered using the complete part number as shown on the adapter pages. Example: Base part number Pipe or port size Tube or hose end aterial designation suffix (carbon steel) S Base part number FOR-SE tube size Pipe or port size aterial designation suffix (carbon steel) FOR-SE tube fitting body without O-rings Example: Base part number dd 1 after base part number to eliminate O-rings FOR-SE tube size Pipe or port size aterial designation suffix (carbon steel) FF1852T S HOSE SSEBY TEHI T 242 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

2 Steel dapters Introduction PPITIO T aterials Eaton connectors are available in a variety of alloys on special order. arbon Steel dapters are precision machined from ISI 1214 carbon steel. Shaped dapters such as elbows and tees with a prefix are made from hi-density forgings. Shaped dapters with a TF prefix are brazed. Straight dapters made from bar stock. Stainless Steel dapters are made from type 316 stainless. Standard Ermeto flareless sleeves are made from 17-4PH precipitation hardened stainless. Finishes Weathercote is an Eaton trademark for a protective coating that far exceeds the minimum requirements of the SE specifications for a corrosion resistant finish for use with petroleumbased, synthetic, and waterbased hydraulic fluids. It is readily identified by its dark appearance. Weathercote is an amorphous phosphate coating covered with a soluble rust-proof film resulting in a coating of.0002" thick, yet providing full protection against electrolytic action, thread seizure or corrosive action of hydraulic fluids. The lubricity of the rustproof solvent film measurably reduces the amount of torque required to make leak-proof connections. Zinc Plated Eaton connectors are given a coating.0002" thick minimum. Stainless Steel Stainless Steel dapters are supplied with natural surface finish except tube nuts which are coated with a bonded dry-film lubricant (black) to reduce assembly torque and prevent galling of threads. ll Eaton Stainless Steel dapters are passivated to remove microscopic foreign particles from the surface of stainless steel as required. Process also leaves a film of corrosion protection. Hydraulic Fluids odern hydraulic systems in use today employ a wide variety of high quality hydraulic fluids. There are three principle types in general use today each best suited for particular conditions. They are discussed here briefly to clarify the fitting finishes compatible with each type. Petroleum or ineral Oil Based Hydraulic Fluids are good general purpose fluids available in a full range of viscosity specified as SE 10, 20, 30, etc. These fluids are not fire resistant making them unsuitable for use where there is a potential source of ignition. Eaton onnectors can be used with these fluids. Straight Synthetic Hydraulic Fluids is a general term applied to such products as Pydraul, indol, ellulubes 90, 150, 180, 220, etc. where fire hazards are high. Weathercote-finish onnectors are recommended for this type of fluid. O-Rings UST be made of a Butyl compound, or they will swell when contacted by synthetic fluids. Water-Based Hydraulic Fluids consist generally of a mixture of water and poly-glycols. They are non-flammable and serve the same purpose as the synthetic types. Only Weathercote-finish onnectors are recommended for this type of fluid. Zinc plate finishes will be dissolved by waterbased fluids and damage to expensive components may result. These waterbased fluids are usually less expensive than synthetic fluids and have little or no detrimental effects on Buna- compounds used in O-Rings. SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS O-Ring ompound and pplication hart Petroleum Base & ineral Straight Water-Based O-Ring aterial Oil-Based Synthetic Hydraulic atalog of hydraulic Hydraulic Fluids lubricating urometer Temp umber ompound Fluids Fluids (Poly-glycols) ir Water Oils hrdness Range F _x252* Buna- Excellent Unsuitable Good Excellent Good Excellent to x* Buna- Excellent Unsuitable Good Excellent Good Excellent to x* Buna- Excellent Unsuitable Good Excellent Good Excellent to x* Buna- Excellent Unsuitable Good Excellent Good Excellent to +250 B7629x* Buna- Excellent Unsuitable Good Excellent Good Excellent to x* Buna- Excellent Unsuitable Good Excellent Good Excellent to +250 ZW747x* Buna- Excellent Unsuitable Good Excellent Good Excellent to +250 *Standard O-Ring complies with SE J-515 Type H and ST specifications ll standard Eaton connectors are supplied with this type O-Ring, unless otherwise specified. (Viton O-Rings are available as special order items only). ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

3 PPITIO T Steel dapters OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES Ordering Information: Each adapter is ordered individually by catalog number. Typical pplication: Grease, instrumentation and most hydraulic systems. Pressure: See chart below. Vibration Rating: Fair resistance. aterial: arbon steel ISI/SE 1214 Stainless steel Type 316 Plating: Zinc; yellow finish. Temperature: -65 F to +400 F. dvantages: ryseal pipe threads (PTF), zinc plate, compact size, and broad selection of styles and sizes. onformance: eets SE specifications. ote: See page 408 for hydraulic O-Ring assortment. abel Set: FS-2000 (dhesive) Seal-ut For ale Pipe Thread PTFE insert Pipe Size 1/16 1/8 1/4 3/8 1/2 3/ /4 1-1/2 2 Thread Size 1/ /8-27 1/4-18 3/8-18 1/2-14 3/ /2 1 1/4-11 1/2 1 1/2-11 1/ /2 Forged Hose Ends and daptors Pipe Hose Ends 3000 Series Pressure Rating hart onnection Type End Size 1/8" 1/4" 3/8" 1/2" 3/4" 1" 1-1/4" 1-1/2" 2" ale Pipe (PTF Female Pipe (PTF) Brazed Hose Ends (TF) Pipe Hose Ends 3000 Series Pressure Rating hart onnection Type End Size 1/8" 1/4" 3/8" 1/2" 3/4" 1" 1-1/4" 1-1/2" 2" ale Pipe (PTF Female Pipe (PTF) Pipe atalog Hex l Thread umber 1/8 3059x2 5/8.15 1/4 3059x4 3/4.25 3/8 3059x6 7/8.25 1/2 3059x8 1-1/8.25 3/4 3059x12 1-5/ x16 1-5/8.34 HOSE SSEBY Hex Socket Plug Socket Hex ale Pipe atalog Socket Thread umber Hex 1/ x1 5/ /8 3169x2 3/ /4 3169x4 1/4.46 TEHI T 244 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

4 Steel dapters Square Head Plug Thread Hex Head Plug Stainless Steel o. 3171x B ale Pipe atalog B Thread umber 1/8 3179x2.25 9/ /4 3179x4.29 3/8.51 3/8 3179x6.32 7/ /2 3179x8.40 9/ /4 3179x / x /16.85 ale Pipe atalog Hex Thread umber Opt. ia. 1/8 3159x2 7/ /4 3159x4 9/ /8 3159x6 11/ /2 3159x8 7/ /4 3159x12 1-1/ x16 1-3/ /4 3159x20 1-3/ /2 3159x x32 2-1/ vailable in Stainless Steel. PPITIO T SPEITY HOSE HIGH OW & EIU Bushing Stainless Steel o. 3121x (Ref. SE o ) ale Female Pipe Pipe atalog Hex Thread Thread umber 1/4 1/8 3109x4x2 5/ /8 1/8 3109x6x2 3/ /8 1/4 3109x6x4 3/ /2 1/8 3109x8x2 7/ /2 1/4 3109x8x4 7/ /2 3/8 3109x8x6 7/ /4 1/4 3109x12x4 1-1/ /4 3/8 3109x12x6 1-1/ /4 1/2 3109x12x8 1-1/ /8 3109x16x6 1-3/ /2 3109x16x8 1-3/ /4 3109x16x12 1-3/ /4 1/2 3109x20x8 1-3/ /4 3/4 3109x20x12 1-3/ / x20x16 1-3/ /2 3/4 3109x24x / x24x /2 1-1/4 3109x24x /4 3109x32x20 2-1/ /2 3109x32x24 2-1/ ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

5 PPITIO T OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES Steel dapters Straight Thread O-Ring to Female Pipe dapter B-Thread Replacement O-rings page 256. dapter Stainless Steel o. 3221x (Ref. SE ) ale FemalE Port Pipe atalog Straight Hex Size Thread umber Thread B 1/4 1/8 3269x4x2 7/ / /4 1/4 3269x4x4 7/ / /16 1/8 3269x5x2 1/2 20 5/ /8 1/4 3269x6x4 9/ / /8 3/8 3269x6x6 9/ / /8 1/2 3269x6x8 9/ / /2 1/4 3269x8x4 3/4 16 7/ /2 3/8 3269x8x6 3/4 16 7/ /2 1/2 3269x8x8 3/ / /8 1/4 3269x10x4 7/ /8 3/8 3269x10x6 7/ /8 1/2 3269x10x8 7/ / /8 3/4 3269x10x12 7/ / /4 1/2 3269x12x8 1-1/ / /4 3/4 3269x12x12 1-1/ / /8 3/4 3269x14x12 1-3/ / /2 3269x16x8 1-5/ / /4 3269x16x12 1-5/ / x16x16 1-5/ / / x20x16 1-5/ / /4 1-1/4 3269x20x20 1-5/ /2 1-1/2 3269x24x24 1-7/ / x32x32 2-1/ / Female ale Pipe Pipe atalog Hex Thread Thread umber 1/4 1/8 3209x4x2 3/ /8 1/4 3209x6x4 7/ /2 1/8 3209x8x2 1-1/ /2 1/4 3209x8x4 1-1/ /2 3/8 3209x8x6 1-1/ /4 1/4 3209x12x4 1-3/ /4 1/2 3209x12x8 1-3/ /2 3209x16x8 1-5/ /4 3209x16x12 1-5/ / x20x /2 1-1/4 3209x24x20 2-3/ /2 3209x32x24 2-7/ vailable in Stainless Steel. HOSE SSEBY Female Straight Thread O-Ring to ale Pipe dapter Fem. ale Port Pipe atalog Straight Hex Size Thread umber Thread B 3/8 3/8 3239x6x6 9/ / /8 1/2 3239x6x8 9/ / /2 3/8 3239x8x6 3/ /2 1/2 3239x8x8 3/ /8 1/2 3239x10x8 7/ / TEHI T 246 B-Thread ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

6 Steel dapters vailable in Stainless Steel. PPITIO T ale Straight Thread O-Ring to ale Pipe dapter Replacement O-rings page 256. oupling Stainless Steel o. 3321x (Ref. SE o ) 1 B-Thread B-Thread ale ale Port Pipe atalog Straight Hex Size Thread umber Thread B 1/4 1/8 3249x4x2 7/ / /8 1/4 3249x6x4 9/ / /2 3/8 3249x8x6 3/4 16 7/ /2 1/2 3249x8x8 3/4 16 7/ /8 1/2 3249x10x8 7/ /4 3/4 3249x12x12 1-1/ / x16x16 1-5/ / /4 1-1/4 3249x20x20 1-5/ / /2 1-1/2 3249x24x24 1-7/ / x32x32 2-1/ / Fem. Fem. Pipe Pipe atalog Hex 1 Thread Thread umber 1/8 1/8 3309x2 5/ /4 1/8 3309x4x2 3/ /4 1/4 3309x4 3/ /8 1/4 3309x6x4 7/ /8 3/8 3309x6 7/ /2 1/4 3309x8x4 1-1/ /2 3/8 3309x8x6 1-1/ /2 1/2 3309x8 1-1/ /4 1/2 3309x12x8 1-3/ /4 3/4 3309x12 1-3/ /4 3309x16x12 1-5/ x16 1-5/ /4 1-1/4 3309x /2 1-1/2 3309x24 2 3/ x32 2 7/ SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS ale For-Seal to ale Pipe dapter 1 Hex HEX Replacement O-rings page 273. Tube ale Pipe atalog Hex 1 O.. Thread umber 3/8 3/8 4205x6x6 3/ /2 3/8 4205x8 7/ /2 1/2 4205x8x8 7/ /8 1/2 4205x10 1-1/ /4 1/2 4205x12x8 1-1/ /4 3/4 4205x12 1-1/ / x12x16 1-3/ x16 1-1/ /4 1-1/4 4205x20 1-3/ ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

7 PPITIO T Steel dapters vailable in Stainless Steel. OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES Hex ipple Stainless Steel o. 3081x (Ref. SE o ) ong ipple P P ale ale Pipe Pipe atalog Hex Thread Thread umber 1/16 1/ x1 5/ /8 1/ x2x1 7/ /8 1/8 3069x2 7/ /4 1/8 3069x4x2 5/ /4 1/4 3069x4 5/ /8 1/8 3069x6x2 3/ /8 1/4 3069x6x4 3/ /8 3/8 3069x6 3/ /2 1/4 3069x8x4 7/ /2 3/8 3069x8x6 7/ /2 1/2 3069x8 7/ /4 1/2 3069x12x8 1-1/ /4 3/4 3069x12 1-1/ /4 3069x16x12 1-3/ x16 1-3/ /4 1-1/4 3069x20 1-3/ /2 1-1/2 3069x x32 2-1/ Part o (ash Size) ash Thread Size P (nptf) mm inches 2S - 3/4 1 / ,0.75 2S / , S - 7/8 1 / ,3.88 6S / , S / , S / , S - 1 1/8 1 / , S - 2 1/2 1 / , S - 1 3/8 3 / , S - 1 1/ / 2 38, HOSE SSEBY PS dapter P1 P2 30 Part o (ash Size) ash Thread Thread Size P1 (PTf) P2 (PS) mm inches 8-8S 1 / / , TEHI T 248 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

8 Steel dapters vailable in Stainless Steel. PPITIO T Bulkhead oupling Pipe Thread Pipe Thread B-Thread Thread Size-B I Bulkhead oupling Pipe Thread Bulkhead oupling I Pipe Thread 1 Female pipe catalog thread hex hex thread number size b c c1 d i 1/4 W / / /4 W / / /8 W /8 1-3/ Pipe Thread 1 E PIPE THRE Thread Size-B E PIPE THRE FEE PIPE THRE FEE PIPE THRE TOG UBER TOG UBER THRE SIZE B THRE SIZE B HEX HEX HEX 1 I 1/2 1/4 W / /4 1-1/ /2 1/4 W / /4 1-1/ Pipe Thread B-Thread HEX 1 I 1/2 1/4 W /4 1-3/ /2 1/4 W /4 1-3/ SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS Pipe Thread Thread I B-Thread Size-B 1 Pipe Thread PTERS & TUBE HOSE ES ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

9 PPITIO T Steel dapters vailable in Stainless Steel. 45 Union Elbow Part o (ash Size) OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY (Ref. SE ) P 1 45 Female Elbow (Ref. SE o ) 45 Street Elbow Stainless Steel o. 3371x (Ref. SE o ) P B ash Thread Thread Size P1 (nptf) P2 (nptf) B mm inches mm inches 4-4S 1 / / , , S 3 / / , , S 1 / / , , S 3 / / , , S / / 2 30, , Fem. PiPE atalog cross Thread umber flats 1/4 3559x /4 3/8 3559x /8 1/2 3559x /16 3/4 3559x / x /8 1/4 TF3559x /4 Fem. ale Pipe Pipe atalog 1 1 cross Thread Thread umber flats 1/8 1/8 3359x /16 1/4 1/4 3359x /4 3/8 3/8 3359x /8 1/2 1/2 3359x /16 3/4 3/4 3359x / x /8 1/8 1/8 TF3359x /8 1/4 1/4 TF3359x /4 3/8 3/8 TF3359x /8 1/2 1/2 TF3359x /8 3/4 3/4 TF3359x /8 1 1 TF3359x /8 1-1/4 1-1/4 TF3359x /2 1-1/2 TF3359x /8 2 2 TF3359x / TEHI T 250 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

10 Steel dapters vailable in Stainless Steel. PPITIO T 90 Female Elbow Stainless Steel o. 3521x (Ref. SE o ) Fem. Fem. Pipe Pipe atalog cross Thread Thread umber Flats 1/8 1/8 3509x /16 1/4 1/4 3509x /4 3/8 3/8 3509x /8 1/2 1/2 3509x /16 3/4 3/4 3509x / x /8 1-1/4 1-1/4 3509x / x /16 1/8 1/8 TF3509x /8 1/4 1/8 TF3509x4x /4 1/4 1/4 TF3509x /4 3/8 1/4 TF3509x6x /8 3/8 3/8 TF3509x /8 1/2 3/8 TF3509x8x /8 1/2 1/2 TF3509x /8 3/4 1/2 TF3509x12x /8 3/4 3/4 TF3509x /8 1 1 TF3509x /8 1-1/4 1-1/4 TF3509x /2 1-1/2 TF3509x /8 SPEITY HOSE HIGH OW & EIU 90 Street Elbow Stainless Steel o. 3421x (Ref. SE o ) 1 1 ale female Pipe Pipe atalog cross Thread Thread umber 1 1 Flats 1/8 1/8 3409x /16 1/4 1/4 3409x /4 3/8 3/8 3409x /8 1/2 1/2 3409x /16 3/4 3/4 3409x / x /8 1-1/4 1-1/4 3409x / x /16 1/8 1/8 TF3409x /8 1/8 1/4 TF3409x2x /4 1/4 1/8 TF3409x4x /8 1/4 1/4 TF3409x /4 1/4 3/8 TF3409x4x /8 3/8 1/4 TF3409x6x /16 3/8 3/8 TF3409x /8 3/8 1/2 TF3409x6x /8 1/2 3/8 TF3409x8x /16 1/2 1/2 TF3409x /8 1/2 3/4 TF3409x8x /8 3/4 1/2 TF3409x12x /8 3/4 3/4 TF3409x /8 1 1 TF3409x /8 1-1/4 1-1/4 TF3409x /2 1-1/2 TF3409x /8 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

11 PPITIO T OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS Steel dapters 90 Straight Thread O-Ring ale Elbow 90 Straight Thread O-Ring Female Elbow ong B-Thread 1 1 B-Thread 1 ale Fem. Port Pipe atalog Straight 1 1 cross Size Thread umber Thread B flats 1/2 3/8 3459x8 3/ /8 5/8 1/2 3459x10 7/ /16 3/4 3/4 3459x12 1-1/ / x16 1-5/ /8 1/4 1/8 TF3459x4 7/ /8 5/16 1/8 TF3459x5 1/ /8 3/8 1/4 TF3459x6 9/ /4 1/2 3/8 TF3459x8 3/ /8 5/8 1/2 TF3459x10 7/ /8 3/4 3/4 TF3459x12 1-1/ /8 7/8 3/4 TF3459x14 1-3/ /8 1 1 TF3459x16 1-5/ /8 1-1/4 1-1/4 TF3459x20 1-5/ /2 1-1/2 TF3459x24 1-7/ /8 2 2 TF3459x32 2-1/ /8 Replacement O-rings page 256. ale 45 Port Fem. Pipe atalog Straight 1 1 cross Size Size umber Thread B flats 1/2 3/8 3469x8 3/ /8 5/8 1/2 3469x10 7/ /16 3/4 3/4 3469x12 1-1/ / x16 1-5/ /8 Replacement O-rings page 256. PTERS & HOSE ES HOSE SSEBY TEHI T 90 Straight Thread O-Ring ale Elbow To ale Pipe B-Thread 1 ale ale Port Pipe atalog Straight 1 1 cross Size Thread umber Thread B flats 1/4 1/8 TF3569x4 7/ /2 5/16 1/8 TF3569x5 1/ /16 3/8 1/4 TF3569x6 9/ /8 1/2 3/8 TF3569x8 3/ /16 5/8 1/2 TF3569x10 7/ /16 3/4 3/4 TF3569x12 1-1/ /8 7/8 3/4 TF3569x14 1-3/ /4 1 1 TF3569x16 1-5/ /8 1-1/4 1-1/4 TF3569x20 1-5/ /4 1-1/2 1-1/2 TF3569x24 1-7/ TF3569x32 2-1/ /8 Replacement O-rings page ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

12 Steel dapters vailable in Stainless Steel. PPITIO T 90 Elbow Hose onnector (Ref. SE ) P 90 ale Elbow Stainless Steel o. 3541x B Part o. FF1162- (ash Size) ash hose Thread Size size P (PTF) B mm inches mm inches mm inches mm inches 1212S 19, / , , , S 25, / 2 43, , , ale ale Pipe Pipe atalog d d1 1 cross Thread Thread umber flats 1/8 1/8 3529x /16 1/4 1/4 3529x /16 3/8 3/8 3529x /4 1/2 1/2 3529x /8 3/4 3/4 3529x /16 1/8 1/8 TF3529x /2 1/4 1/4 TF3529x /8 3/8 1/4 TF3529x6x /16 3/8 3/8 TF3529x /16 1/2 3/8 TF3529x8x /16 1/2 1/2 TF3529x /16 3/4 1/2 TF3529x12x /8 3/4 3/4 TF3529x /8 1 3/4 TF3529x16x /8 1 1 TF3529x /8 1-1/4 1-1/4 TF3529x /4 1-1/2 1-1/2 TF3529x SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS ale Pipe Swivel to Female Pipe Rigid P1 P2 B Part o (ash Size) 1 ash Thread Thread Size P1 (nptf) P2 (nptf) B mm inches mm inches 4-4S 1 / / , , S 3 / / , , S 1 / / , , S 3 / / , , ot for use in applications over +212 F. ot intended to be a live swivel. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

13 PPITIO T Steel dapters Union Tee Part o (ash Size) vailable in Stainless Steel. OW & EIU P P B ash Thread size p (nptf) b B mm inches mm inches 4-4S 1 / , , S 3 / , , S 1 / , , S 3 / , , HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY Tee Stainless Steel o. 3721x (Ref. SE o ) ale Branch Tee Stainless Steel o. 3621x (Ref. SE o ) 1 Fem. PiPE atalog cross Thread umber flats 1/8 3709x /16 1/4 3709x /4 3/8 3709x /8 1/2 3709x /16 3/4 3709x / x /8 1-1/4 3709x /8 1/8 TF3709x /8 1/4 TF3709x /4 3/8 TF3709x /8 1/2 TF3709x /8 3/4 TF3709x /8 1 TF3709x /8 1-1/4 TF3709x /2 TF3709x /8 2 TF3709x /8 ale Fem. Pipe Pipe atalog d d1 cross Thread Thread umber flats 1/8 1/8 3609x /16 1/4 1/4 3609x / x /8 1/8 1/8 TF3609x /8 1/4 1/4 TF3609x /4 3/8 3/8 TF3609x /8 1/2 1/2 TF3609x /8 3/4 3/4 TF3609x /8 1 1 TF3609x /8 1-1/4 1-1/4 TF3609x /2 1-1/2 TF3609x /8 TEHI T 254 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

14 Steel dapters ale Run Tee Stainless Steel o. 3771x (Ref. SE o ) Female Run Tee 1 1 vailable in Stainless Steel. Fem. ale Pipe Pipe atalog 1 cross Thread Thread umber flats 1/8 1/8 3759x /16 1/4 1/4 3759x /4 3/8 3/8 3759x /8 1/2 1/2 3759x /16 3/4 3/4 3759x / x /8 1/8 1/8 TF3759x /8 1/4 1/4 TF3759x /4 3/8 3/8 TF3759x /8 1/2 1/2 TF3759x /8 3/4 3/4 TF3759x /8 1 1 TF3759x /8 1-1/4 1-1/4 TF3759x /2 1-1/2 TF3759x /8 2 2 TF3759x /8 Fem. ale Pipe Pipe atalog 1 cross Thread Thread umber flats 1/8 1/8 TF3805x /8 1/4 1/4 TF3805x /4 3/8 3/8 TF3805x /8 1/2 1/2 TF3805x /8 3/4 3/4 TF3805x /8 1 1 TF3805x /8 1-1/4 1-1/4 TF3805x /2 1-1/2 TF3805x /8 PPITIO T SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS Female Branch Tee P1 P1 P2 B Part o (ash Size) ash Thread Thread Size P1 (nptf) P2 (nptf) B mm inches mm inches 4-4S 1 / / , , S 3 / / , , S 1 / / , , S 3 / / , , ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

15 PPITIO T Steel dapters OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS ross ross P2 P1 B P2 B B Fem. PiPE atalog cross Thread umber flats 3/8 3959x /8 1/2 3959x /16 3/4 3959x /16 1/8 TF3959x /8 1/4 TF3959x /4 3/8 TF3959x /8 1/2 TF3959x /8 3/4 TF3959x /8 1 TF3959x /8 1-1/4 TF3959x /2 TF3959x /8 2 TF3959x /8 Part o (ash Size) ash Thread Thread Size P1 (PTF) P2 (nptf) B mm inches mm inches 4-4S 1 1 / / , , S 1 / / , , PTERS & HOSE ES HOSE SSEBY Straight Thread O-Ring I.. aterial: Buna-, 90 urometer Temperature Range: -40 F to +250 F (-40 to +121 ) Standard O-Ring complies with SE specification SE J515 Type H. (See page 343 for O-Ring compound and application chart.) W Tube atalog W I.. O.. umber 1/ x /8 7629x / x /4 7629x / x /8 7629x / x /2 7629x /8 7629x /4 7629x /8 7629x x /4 7629x /2 7629x x TEHI T 256 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

16 Steel onnectors Swivel dapters PPITIO T 9000 Pipe onnectors Typical pplication: Pressure hydraulic systems. Pressure: See chart. Sealing ethod: etal to metal, 30 cone-ps thread on pipe swivel end. Sealing methods vary depending on swivel adapter type. aterial: arbon steel Plating: Zinc Pipe Hose Ends 9000 Series Pressure Rating hart onnection Type End Size 1/8" 1/4" 3/8" 1/2" 3/4" 1" 1-1/4" 1-1/2" 2" ale Pipe (PTF)* Female Pipe (PTF)* * Pressure ratings shown are the pressure ratings for the fitting and are not necessarily the pressure ratings applicable in an assembly with hydraulic hose. The applicable pressure rating for an assembly with hydraulic hose is the lower value specified for the hose and the fitting unless otherwise agreed to by the supplier and user. SPEITY HOSE HIGH OW & EIU Female Pipe Swivel to ale Pipe (Ref. SE o ) Psm mle Pipe atalog Hex Swivel ut Thread umber 1/8 27 1/ x2x2 9/ /8 27 1/ x2x4 11/ /4 18 1/ x4x2 11/ /4 18 1/ x4x4 11/ /4 18 3/ x4x6 11/ /4 18 1/ x4x8 7/ /8 18 1/ x6x4 5/ /8 18 3/ x6x6 3/ /8 18 1/ x6x8 7/ /2 14 3/ x8x6 7/ /2 14 1/ x8x /2 14 3/ x8x12 1-1/ /4 14 1/ x12x /4 14 3/ x12x12 1-1/ / /2 9205x12x16 1-1/ /2 3/ x16x12 1-1/ / /2 9205x16x16 1-1/ /2 1-1/4 11-1/2 9205x16x / /4 11-1/ /2 9205x20x16 1-7/ /4 11-1/2 1-1/4 11-1/2 9205x20x20 1-7/ /4 11-1/2 1-1/2 11-1/2 9205x20x24 2-1/ /2 11-1/2 1-1/4 11-1/2 9205x24x20 2-1/ /2 11-1/2 1-1/2 11-1/2 9205x24x24 2-1/ / /2 9205x32x32 2-5/ ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

17 PPITIO T Steel onnectors Swivel dapters OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY TEHI T Female 37 JI Swivel to ale Pipe dapter 258 Female Pipe Swivel to Female Pipe Straight (Ref. SE o ) ale Straight Thread O-Ring to Female Pipe Swivel (Ref. SE o ) Tube ale Pipe atalog Hex O.. Thread umber 1/4 1/4 9100x4x4 9/ /16 1/4 9100x5x4 11/ /8 1/4 9100x6x4 11/ /8 3/8 9100x6x6 11/ /2 3/8 9100x8x6 7/ /2 1/2 9100x8x8 7/ /8 3/8 9100x10x /8 1/2 9100x10x /4 1/2 9100x12x8 1-1/ /4 3/4 9100x12x12 1-1/ /4 9100x16x12 1-3/ x16x16 1-3/ /4 1 1/4 9100x20x20 1-7/ Psm fem. Pipe atalog Hex Swivel ut Thread umber 1/8 27 1/ x2x2 9/ /4 18 1/ x4x4 11/ /4 18 3/ x4x6 7/ /8 18 1/ x6x4 11/ /8 18 3/ x6x6 7/ /8 18 1/ x6x /2 14 3/ x8x /2 14 1/ x8x /4 14 3/ x12x12 1-1/ / /2 9255x12x16 1-1/ / /2 9255x16x16 1-1/ /4 11-1/2 1-1/4 11-1/2 9255x20x20 1-7/ /2 11-1/2 1-1/2 11-1/2 9255x24x24 2-1/ / /2 9255x32x32 2-5/ Straight Psm atalog Hex Thread swivel ut umber 7/ / x4x4 9/ / / x4x6 5/ /2 20 1/ x5x4 5/ / / x6x4 11/ / / x6x6 11/ / / x6x8 13/ /4 16 1/ x8x4 7/ /4 16 3/ x8x6 7/ /4 16 1/ x8x8 7/ /4 16 3/ x8x /4 14 3/ x10x /4 14 1/ x10x /4 14 3/ x10x / / x12x8 1-1/ / / x12x12 1-1/ / / x14x12 1-3/ / / x16x12 1-1/ / /2 9315x16x16 1-1/ / /2 9315x20x16 1-7/ / /4 11-1/2 9315x20x20 1-7/ / /2 11-1/2 9315x24x24 2-1/ / /2 9315x32x32 2-3/ Replacement o-rings page 256. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

18 Steel onnectors Swivel dapters PPITIO T 45 Swivel Elbow Female Pipe Swivel to ale Pipe (Ref. SE o ) 45 Swivel Elbow Female Pipe Swivel to Female Pipe (Ref. SE o ) Swivel Elbow Female 45 SE to ale 45 SE (Steel) Psm mle Pipe atalog Hex Swivel ut Thread umber 1 1/8 27 1/ x2x2 9/ /4 18 1/ x4x2 11/ /4 18 1/ x4x4 11/ /4 18 3/ x4x6 7/ /4 18 1/ x4x /8 18 1/ x6x4 7/ /8 18 3/ x6x6 7/ /8 18 1/ x6x /2 14 3/ x8x /2 14 1/ x8x /2 14 3/ x8x12 1-1/ /4 14 1/ x12x8 1-1/ /4 14 3/ x12x12 1-1/ / /2 9355x12x16 1-1/ /2 3/ x16x12 1-1/ / /2 9355x16x16 1-1/ /2 1-1/4 11-1/2 9355x16x20 1-7/ /4 11-1/2 1-1/4 11-1/2 9355x20x20 1-7/ /2 11-1/2 1-1/2 11-1/2 9355x24x24 2-1/ / /2 9355x32x32 2-5/ Psm fem. Pipe atalog Hex Swivel ut Thread umber 1 1/8 27 1/ x2x2 1/ /4 18 1/ x4x4 11/ /4 18 3/ x4x6 7/ /8 18 3/ x6x6 7/ /8 18 1/ x6x /2 14 1/ x8x /4 14 3/ x12x12 1-1/ / /2 9385x12x16 1-1/ / /2 9385x16x16 1-1/ /4 11-1/2 1-1/4 11-1/2 9385x20x20 1-7/ /2 11-1/2 1-1/2 11-1/2 9385x24x24 2-1/ / /2 9385x32x32 2-5/ Tube atalog Hex O.. umber 1 3/8 9154x6x6 3/ /2 9154x8x /8 9154x10x10 1-1/ SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES 1 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

19 PPITIO T Steel onnectors Swivel dapters OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY 45 Swivel Elbow ale Straight Thread O-Ring to Female Pipe Swivel 45 Elbow (Ref. SE o ) 1 90 Elbow Female Pipe Swivel to ale Pipe (Ref. SE o ) 1 Straight Psm atalog Hex Thread swivel ut umber 1 7/ / x4x4 11/ / / x4x6 7/ / / x6x6 7/ / / x6x /4 16 3/ x8x /4 16 1/ x8x /8 14 1/ x10x / / x12x12 1-1/ / /2 9365x16x16 1-1/ / /4 11 1/2 9365x20x20 1-7/ / /2 11 1/2 9365x24x24 2-1/ Replacement o-rings page 256. Psm mle Pipe atalog Hex Swivel ut Thread umber 1 1/8 27 1/ x2x2 9/ /8 27 1/ x2x4 11/ /4 18 1/ x4x2 11/ /4 18 1/ x4x4 11/ /4 18 3/ x4x6 11/ /4 18 1/ x4x /8 18 1/ x6x4 13/ /8 18 3/ x6x6 7/ /8 18 1/ x6x /8 18 3/ x6x12 1-1/ /2 14 3/ x8x /2 14 1/ x8x /2 14 3/ x8x12 1-1/ / /2 9405x8x16 1-1/ /4 14 3/ x12x12 1-1/ / /2 9405x12x16 1-1/ /2 3/ x16x12 1-1/ / /2 9405x16x16 1-1/ /2 1-1/4 11-1/2 9405x16x20 1-7/ /4 11-1/ /2 9405x20x16 1-7/ /4 11-1/2 1-1/4 11-1/2 9405x20x20 1-7/ /4 11-1/2 1-1/2 11-1/2 9405x20x24 2-1/ /2 11-1/2 1-1/2 11-1/2 9405x24x24 2-1/ / /2 9405x32x32 2-5/ TEHI T 260 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

20 Steel onnectors Swivel dapters PPITIO T 90 Elbow Female Pipe Swivel to Female Pipe (Ref. SE o ) 1 90 Elbow 45 SE Female Swivel to SE 45 ale (Steel) 1 Psm fem. Pipe atalog Hex Swivel ut Thread umber 1 1/8 27 1/ x2x2 9/ /4 18 1/ x4x4 11/ /4 18 3/ x4x6 13/ /4 18 1/ x4x /8 18 1/ x6x4 13/ /8 18 3/ x6x6 13/ /8 18 1/ x6x /2 14 3/ x8x /2 14 1/ x8x /2 14 3/ x8x12 1-1/ /4 14 1/ x12x8 1-1/ /4 14 3/ x12x12 1-1/ / /2 9455x12x16 1-1/ /2 3/ x16x12 1-1/ / /2 9455x16x16 1-1/ /4 11-1/2 1-1/4 11-1/2 9455x20x20 1-7/ /2 11-1/2 1-1/2 11-1/2 9455x24x24 2-1/ / /2 9455x32x32 2-5/ TuBE atalog Hex O.. umber 1 3/8 9151x6x6 3/ /2 9151x8x /8 9151x10x10 1-1/ SPEITY HOSE HIGH OW & EIU 90 Elbow ale Straight Thread O-Ring to Female Pipe Swivel (Ref. SE o ) 1 Straight Psm atalog Hex Thread swivel ut umber 1 7/ / x4x4 11/ / / x4x6 7/ / / x6x4 11/ / / x6x6 7/ / / x6x /4 16 3/ x8x /4 16 1/ x8x /4 16 3/ x8x12 1-1/ /8 14 3/ x10x /8 14 1/ x10x /8 14 3/ x10x12 1-1/ / / x12x8 1-1/ / / x12x12 1-1/ / / x14x12 1-1/ / / x16x12 1-1/ / /2 9515x16x16 1-1/ /8 12 3/ x20x12 1-7/ / /4 11-1/2 9515x20x20 1-7/ / /2 11-1/2 9515x24x24 2-1/ / x32x32 2-5/ Replacement o-rings page 256. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

21 PPITIO T Steel onnectors Swivel dapters OW & EIU 90 Elbow ale Pipe Swivel to ale Pipe Rigid ale Pipe ale Pipe atalog Hex Swivel Rigid umber 1 1/4 18 1/ x4x4 9/ /8 18 3/ x6x6 3/ /2 14 1/ x8x8 7/ ot for use with liquids over 212 F. HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY Female Pipe Swivel Tee Female Pipe Swivel to ale Pipe Branch Tee Female Pipe Swivel to Female Pipe Branch Tee Psm atalog Hex Swivel umber 1 1/ x2x2x2 1/ / x4x4x4 11/ / x6x6x6 7/ / x8x8x / x12x12x12 1-1/ /2 9705x16x16x16 1-1/ /4 11 1/2 9705x20x20x20 1-7/ PS Swivel mle atalog Hex Thread PiPE umber 1 1/8 27 1/ x2x2x2 9/ /4 18 1/ x4x4x4 11/ /4 18 3/ x4x4x6 7/ /4 18 1/ x4x4x8 7/ /8 18 3/ x6x6x /8 18 1/ x6x6x /2 14 1/ x8x8x /2 14 3/ x8x8x12 1-1/ / /2 9406x12x12x16 1-1/ /2 3/ x16x16x12 1-1/ / /2 9406x16x16x16 1-1/ /4 11-1/2 1-1/4 11-1/2 9406x20x20x20 1-7/ /2 11-1/2 1-1/2 11-1/2 9406x24x24x24 2-1/ PS Swivel female atalog Hex Thread PiPE umber 1 1/8 27 1/ x2x2x2 1/ /4 18 1/ x4x4x4 11/ /4 18 3/ x4x4x6 7/ /8 18 3/ x6x6x6 7/ /8 18 1/ x6x6x /2 14 1/ x8x8x /2 14 3/ x8x8x12 1-1/ /4 14 3/ x12x12x12 1-1/ / /2 9456x12x12x16 1-1/ / /2 9456x16x16x16 1-1/ /4 11-1/2 1-1/4 11-1/2 9456x20x20x20 1-7/ TEHI T 262 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

22 FOR-SE Introduction PPITIO T Ordering Information: Use catalog number. Typical pplication: High pressure, hydraulic, pneumatic and chemical processing. Pressure:* Working pressure to 6000 PSI (1-1/4" and 1-1/2"; maximum 4000 PSI). Sealing ethod: O-Ring. Vibration Rating: Excellent resistance. aterial: Generally 1214 steel Plating: Eaton arbon Steel onnectors are zinc-plated, except brazed parts which are oil dipped. Used With: Steel tubing (tubing for brazing must be non-coated). dvantages: Tubing is brazed for permanent leakproof connection. onformance: n exclusive item with Eaton, meets SE J1453. abel Set: FS-2400 ote: See page 408 for new hydraulic O-Ring assortment. * Pressure ratings shown are the pressure ratings for the fitting and are not necessarily the pressure rating applicable in an assembly with hydraulic hose. The applicable pressure rating for an assembly with hydraulic hose is the lower value specified for the hose and the fitting. Tube O.. 1/4 3/8 1/2 5/8 3/4 Thread 9/ / / /16-12 Tube O.. 7/ /4 1-1/2 Thread 1 3/ / / SPEITY HOSE HIGH OW & EIU Tube Preparation and leaning Figure 1 1. Establish the length of tubing required allowing 1/16 cut-off factor for each connection. 2. ut the tubing to proper length keeping ends reasonably square. fine tooth hack saw or cut-off saw works well for this job. The use of a tubing cutter is not recommended due to possible collapse of the tube end, retarding the capillary action required for proper braze flow. ote: Subtract 1/16 from tube length for each connection. 3. lean the end of the tube with an alkaline cleaner to remove all traces of oil or grease. eburr the end of the tube with a file and polish the outside of the tube down to bare metal with clean emery paper. Oil and grease residue must be removed first to avoid working the oily residue into the tube surface. 4. fter polishing, wipe off any metal particles using a clean solvent if necessary. void touching the tube end after final cleaning as this may leave greasy spots which will braze poorly. lean the tailpiece with an alkaline cleaner. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

23 PPITIO T FOR-SE OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES Fluxing and Brazing leanup Flux may be cleaned up using hot water and wire brush, using care not to scratch the tailpiece sealing surface. 1. ssemble proper size braze ring into counterbore of tailpiece. The correct size brazing will be slightly smaller than the inside diameter of the counterbore. Torque Requirements 2. lamp the tube securely in a vise, slide nut on tube, with threads pointing outward. oat the tube end with flux and several inches of the tube outside diameter. 3. oat the tailpiece liberally with flux including the counterbore and braze ring. 4. In a well ventilated area, apply heat uniformly to the tailpiece and the tube end. Watch the flux. The flux becomes completely clear when it is close to the proper brazing temperature. When ring melts, the tailpiece will settle down onto the end. ote: General working knowledge of cetylene torch brazing techniques is recommended. 5. Remove tube assembly from vise and check braze joint. 6. The braze alloy will flow down through the joint and should form a continuous fillet at the tube to tailpiece joint. ote: o not overheat. Excessive heat will only cause scaling and charred flux and make the parts more difficult to clean up. Tube O.. 1/4 3/8 1/2 5/8 3/ /4 1-1/2 Torque Ft-b For-Seal SW. ut Torque Ft-b O-Ring Boss Straight Thread O-Ring ocknut Torque Thread hart Rated pressures are for low surge, static type applications. Tube O.. 1/4 3/8 1/2 5/8 3/ /4 1-1/2 For-Seal Thread 9/ / / / / / aximum PSI djustable Hose Ends PSI HOSE SSEBY TEHI T 264 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

24 FOR-SE Tailpiece Silver Braze (Ref. SE o ) FOR-SE Braze dapter (Ref. SE ) FOR-SE admium Free Braze Ring Part o. FF1851T(Size)* O.. O.. W W TUBE TOG O.. UBER 1 1 1/4 4165x /8 4165x /2 4165x /8 4165x /4 4165x x /4 4165x /2 4165x Oil ipped ash TuBE Thread Size O.. T1 B f mm inches mm inches mm inches mm inches 1212S 19, / , , , *Eaton counterbores are dimensioned for sizes or emeryed tubing. If tubing is used as received, contact Eaton for appropriate part number. TUBE TOG WIRE O.. UBER I. O.. 1/4 4640x /8 4640x /2 4640x /8 4640x /4 4640x x /4 4640x /2 4640x PPITIO T SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS Bulkhead ut (Ref. SE o ) ut (Ref. SE o ) TUBE atalog HEX O.. UBER 1/4 4924x4 13/ /8 4924x /2 4924x8 1-1/8.35 5/8 4924x10 1-5/ /4 4924x12 1-1/ x16 1-3/ /4 4924x /2 4924x24 2-3/8.41 TUBE TOG HEX O.. UBER 1/4 4105x4 11/ /8 4105x6 13/ /2 4105x8 15/ /8 4105x10 1-1/ /4 4105x12 1-3/ x16 1-5/ /4 4105x20 1-7/ /2 4105x24 2-1/ ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

25 PPITIO T FOR-SE OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES ap (Ref. SE o ) Plug (Ref. SE o ) Union (Ref. SE o ) Hex HEX Hex HEX 1 TUBE TOG HEX O.. UBER 1/4 4129x4 11/ /8 4129x6 13/ /2 4129x8 15/ /8 4129x10 1-1/ /4 4129x12 1-3/ x16 1-5/ /4 4129x20 1-7/ /2 4129x24 2-1/ TUBE TOG HEX O.. UBER 1/4 4229x4 5/ /8 4229x6 3/ /2 4229x8 7/ /8 4229x10 1-1/ /4 4229x12 1-1/ x16 1-1/ /4 4229x20 1-3/ /2 4229x24 2-1/ FOR-SE O-Ring included. TUBE TUBE TOG HEX O.. O.. UBER 1 1/4 1/4 4305x4 5/ /8 1/4 4305x6x4 3/ /8 3/8 4305x6 3/ /2 3/8 4305x8x6 7/ /2 1/2 4305x8 7/ /8 1/2 4305x10x8 1-1/ /8 5/8 4305x10 1-1/ /4 1/2 4305x12x8 1-1/ /4 5/8 4305x12x10 1-1/ /4 3/4 4305x12 1-1/ /4 4305x16x12 1-1/ x16 1-1/ /4 1-1/4 4305x20 1-3/ /2 1-1/2 4305x24 2-1/ HOSE SSEBY TEHI T Bulkhead Union (Ref. SE o ) 266 Hex HEX TUBE TOG HEX O.. UBER I 3/8 4325x /2 4325x8 1-1/ /4 4325x12 1-1/ x16 1-3/ /4 4325x /2 4325x24 2-3/ For bulkhead nut, see page 265. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

26 FOR-SE PPITIO T FOR-SE Reducer dapter (Ref. SE ) Straight Thread O-Ring onnector (Ref. SE o ) Part o. FF2281T(Size) ash Tube Thread Thread Size O.. T1 T2 mm inches mm inches 0406S 9, / / , S 12, / / , S 12, / / , S 19, / / , S 19, / / , Hex HEX E E TUBE PORT TOG HEX O.. SIZE UBER 1 1/4 1/4 4315x4 5/ /4 3/8 4315x4x6 11/ /8 1/4 4315x6x4 3/ /8 3/8 4315x6 3/ /8 1/2 4315x6x8 7/ /8 5/8 4315x6x10 1-1/ /2 3/8 4315x8x6 7/ /2 1/2 4315x8 7/ /2 5/8 4315x8x /2 3/4 4315x8x12 1-1/ /8 5/8 4315x10 1-1/ /4 3/4 4315x12 1-1/ / x12x16 1-1/ /4 4315x16x12 1-1/ x16 1-1/ /4 4315x16x20 1-7/ / x20x16 1-3/ /4 1-1/4 4315x20 1-7/ /2 1-1/2 4315x24 2-1/ SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS Straight Thread O-Ring Extended (Ref. SE o ) ale 37 to Female FOR-SE 1 Hex HEX 1 E E TUBE PORT TOG HEX O.. SIZE UBER I 3/8 3/8 4316x6 3/ /2 1/2 4316x8 7/ /4 3/4 4316x12 1-1/ x16 1-1/ /4 1-1/4 4316x20 1-7/ /2 1-1/2 4316x24 2-1/ For replacement Straight Thread O-Ring, see page 273. Female male tube tube atalog Hex hex o.d. size number c c1 d l 1/4 1/4 4213x4 11/16 5/ /8 3/8 4213x6 13/16 3/ /2 1/2 4213x8 15/16 7/ /8 5/8 4213x10 1-1/8 1-1/ /4 3/4 4213x12 1-3/8 1-1/ x16 1-5/8 1-1/ ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

27 PPITIO T FOR-SE OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY TEHI T ale FOR-SE ale Pipe dapter 45 ale Elbow Straight Thread O-Ring onnector 45 Elbow (Ref. SE o ) HEX 1 1 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ale tube pipe catalog hex o.d. size number c d d1 l 3/8 3/8 4205x6x6 3/ /2 3/8 4205x8 7/ /2 1/2 4205x8x8 7/ /8 1/2 4205x10 1-1/ /4 1/2 4205x12x8 1-1/ /4 3/4 4205x12 1-1/ / x12x16 1-3/ x16 1-1/ /4 1-1/4 4205x20 1-3/ ale male tube tube catalog ROss o.d. thread number d d1 m n flats 1/4 1/8 4355x /16 3/8 1/4 4355x /4 1/2 3/8 4355x /8 5/8 1/2 4355x /16 3/4 3/4 4355x / x /8 1-1/4 1-1/4 4355x /8 1-1/2 1-1/2 4355x /8 E E TUBE PORT TOg ROSS O.. SIZE UBER 1 1 FTS 1/4 1/4 4365x /16 1/4 3/8 4365x4x /4 3/8 1/4 4365x6x /4 3/8 3/8 4365x /4 3/8 1/2 4365x6x /4 1/2 3/8 4365x8x /4 1/2 1/2 4365x /4 1/2 5/8 4365x8x /16 1/2 3/4 4365x8x /16 5/8 1/2 4365x10x /16 5/8 5/8 4365x /16 5/8 3/4 4365x10x /16 3/4 5/8 4365x12x /16 3/4 3/4 4365x /16 3/ x12x /16 1 3/4 4365x16x / x / /4 4365x16x /8 1-1/4 1-1/4 4365x /8 1-1/2 1-1/2 4365x /8 For replacement straight thread O-Ring, see page 273.

28 FOR-SE PPITIO T 45 Bulkhead Elbow (Ref. SE o ) Union 90 Elbow (Ref. SE o ) E TUBE TOg ROSS O.. UBER 1 FTS 1/4 4375x /16 3/8 4375x /4 1/2 4375x /4 5/8 4375x /16 3/4 4375x / x /16 1-1/4 4375x /16 1-1/2 4375x /8 For Bulkhead ut, see page 265. ale TUbe catalog cross o.d. number d m flats 1/4 4505x /16 3/8 4505x /4 1/2 4505x /4 5/8 4505x /16 3/4 4505x / x /16 1-1/4 4505x /8 1-1/2 4505x /8 SPEITY HOSE HIGH OW & EIU Bulkhead Union 90 Elbow (Ref. SE o ) 1 1 I ale tube port catalog ROss o.d. size number d d1 m m1 1 flats 1/4 1/4 4525x /16 3/8 3/8 4525x /4 1/2 1/2 4525x /8 5/8 5/8 4525x /16 3/4 3/4 4525x / x /8 1-1/4 1-1/4 4525x /8 1-1/2 1-1/2 4525x /8 For Bulkhead ut, see page 265. ESSORRIES & S BY ISTRUTIOS 90 ale Elbow 1 ale Tube port catalog ROss o.d. size number d d1 m n flats 1/4 1/8 4405x /16 3/8 1/4 4405x /4 1/2 3/8 4405x /4 5/8 1/2 4405x /16 3/4 3/4 4405x / x /8 1-1/4 1-1/4 4405x /8 1-1/2 1-1/2 4405x /8 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

29 PPITIO T OW & EIU FOR-SE 90 Swivel Elbow (Ref. SE o ) male female tube port catalog hex ROss o.d. O.d. number c d d1 m m1 flats 1/4 1/4 4506x4 11/ /16 3/8 3/8 4506x6 13/ /4 1/2 3/8 4506x8x6 13/ /4 1/2 1/2 4506x8 15/ /4 5/8 5/8 4506x10 1-1/ /16 3/4 3/4 4506x12 1-3/ / x16 1-5/ /16 1-1/4 1-1/4 4506x20 1-7/ /8 1-1/2 1-1/4 4506x24x20 1-7/ /8 1-1/2 1-1/2 4506x24 2-1/ /8 HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES Straight Thread O-Ring 90 Elbow (Ref. SE o ) 1 1 E TUBE PORT TOg ROSS O.. SIZE UBER 1 1 FTS 1/4 1/4 4515x /16 1/4 3/ x4x /16 1/4 5/ x4x /16 1/4 3/8 4515x4x /4 1/4 1/2 4515x4x /4 3/8 1/4 4515x6x /4 3/8 5/ x6x /4 3/8 3/8 4515x /4 3/8 1/2 4515x6x /4 3/8 5/8 4515x6x /4 3/8 3/4 4515x6x /16 1/2 5/8 4515x8x /16 1/2 3/4 4515x8x /16 1/2 3/8 4515x8x /4 1/2 1/2 4515x /4 5/8 5/8 4515x /16 5/8 3/4 4515x10x /16 5/8 1/2 4515x10x /16 3/4 5/8 4515x12x /16 3/4 3/4 4515x /16 3/ x12x /16 3/4 1/2 4515x12x /16 1 3/4 4515x16x /8 1 7/8 4515x16x / x / /4 4515x16x /8 1-1/ x20x /8 1-1/4 1-1/4 4515x /8 1-1/4 1-1/2 4515x20x /8 1-1/2 1-1/4 4515x24x /8 1-1/2 1-1/2 4515x /8 For replacement straight thread O-Ring, see page 273. HOSE SSEBY TEHI T Straight Thread O-Ring 90 Elbow - ong B Thread Thread ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006 male male Tube port catalog ROss o.d. size number d d1 m n flats 1/4 1/4 4515x /16 3/8 3/8 4515x /4 1/2 1/2 4515x /4 5/8 5/8 4515x /16 3/4 3/4 4515x / x /16 1-1/4 1-1/4 4515x /8 1-1/2 1-1/2 4515x /8

30 FOR-SE 90 Straight Thread Swivel (Ref. SE o ) Union Tee (Ref. SE o ) 1 Straight Thread Branch Tee (Ref. SE o ) B B 2 fem. tube port catalog hex across o.d. size number d d1 m m1 c flats 1/4 1/4 4535x /16 9/16 3/8 3/8 4535x /16 3/4 1/2 1/2 4535x /16 7/8 5/8 5/8 4535x /8 1-1/16 3/4 3/4 4535x /8 1-3/ x /8 1-5/8 1-1/4 1-1/4 4535x /8 1-5/8 1-1/2 1-1/2 4535x /4 1-7/8 ale male male Tube tube tube catalog ROss o.d. a o.d. b o.d. c number d d1 m m1 m2 flats 1/4 1/4 1/4 4705x /16 3/8 3/8 3/8 4705x /4 3/8 3/8 1/2 4705x6x6x /4 1/2 3/8 1/2 4705x8x6x /4 1/2 1/2 1/2 4705x /4 5/8 5/8 5/8 4705x /16 3/4 3/4 3/4 4705x / x /8 1-1/4 1-1/4 1-1/4 4705x /8 1-1/4 1-1/ x20x20x /8 1-1/2 1-1/2 1-1/2 4705x / Hex HEX 1 TUBE PORT TOg ROSS O.. SIZE UBER 1 1 FTS 1/4 1/4 4715x /16 1/4 3/ x4x /16 3/8 3/8 4715x /4 3/8 1/2 4715x6x /8 1/2 3/8 4715x8x /4 1/2 1/2 4715x /4 5/8 5/8 4715x /16 3/4 3/4 4715x /16 3/ x12x / x /8 1-1/ x20x /16 1-1/4 1-1//4 4715x /8 1-1/2 1-1/2 4715x /8 For replacement straight thread O-Ring, see page 273. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PPITIO T SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

31 PPITIO T FOR-SE OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY Female Branch Tee (Ref. SE o ) Female Run Tee (Ref. SE o ) Straight Thread Run Tee (Ref. SE o ) B B TOg TuBE Thread thread UBER O T1 T2 B 4707x4.25 9/ / x / / x / / x x / / x / / x / / x TOg TuBE Thread thread UBER O T1 T2 B 4706x4.25 9/ / x / / x / / x x / / x / / x / / x E E E TUBE TUBE TUBE TOg ROSS O.. O.. B O.. UBER 1 1 FTS 1/4 1/4 1/4 4716x /16 1/4 1/4 3/8 4716x4x /4 3/8 3/8 3/8 4716x /4 1/2 1/2 1/2 4716x /8 5/8 5/8 5/8 4716x /16 3/4 3/4 3/4 4716x /16 3/4 3/ x12x /16 3/4 1 3/4 4716x12x16x / /4 4716x16x / x /16 1-1/4 1-1/4 1-1/4 4716x /8 1-1/2 1-1/2 1-1/2 4716x /8 For replacement straight thread O-Ring, see page 273. TEHI T 272 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

32 FOR-SE PPITIO T Bulkhead Run Tee (Ref. SE o ) ale FOR-SE ross O-Ring, FOR-SE aterial: Buna, 90 urometer 1 Temperature: -40 F to +250 F (-40 to +121 ) 2 2 Standard O-Ring complies with SE specification SE J515 Type H I I Tube catalog cross o.d. number d i m m1 m2 flats 1/4 4726x /16 3/8 4726x /4 1/2 4726x /4 5/8 4726x /16 3/4 4726x / x /16 1-1/4 4726x /8 1-1/2 4726x /8 For Bulkhead ut, see page 265. Tube TOg ROSS O.. UBER FTS 1/4 4955x /16 3/8 4955x /4 1/2 4955x /8 5/8 4955x /16 3/4 4955x / x /8 1-1/4 4955x /8 1-1/2 4955x /8 TUBE TOG O.. UBER W i.. 1/4 4629x4.070 ± ±.005 3/8 4629x6.070 ± ±.005 1/2 4629x8.070 ± ±.005 5/8 4629x ± ±.005 3/4 4629x ± ± x ± ± /4 4629x ± ± /2 4629x ± ±.010 SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

33 PPITIO T JI 37 Flare-Twin OW & EIU Tube O.. 1/8 3/16 1/4 5/16 3/8 1/2 5/8 3/4 7/ /4 1-1/2 2 Thread Size-B 5/ /8 24 7/ /2 20 9/ /4 16 7/ / / / / / /2 12 HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY TEHI T Forged dapters 5000 Series Pressure Rating hart onnection Type Typical pplication Hydraulic, instrumentation and chemical processing systems. Pressure Refer to the pressure charts above. The maximum working pressure of an adapter is the lower working pressure of the end size. Ex: 3069x8x6, 8 = 4000 psi and 6 = 5000 psi. aximum working pressure is 4000 psi. Vibration Good resistance. Vibration resistance decreases with increase in tube size. Use two piece design when greater vibration resistance is required. Temperature Range -65 F to +400 F (-53 to +204 ) at maximum operating pressures. aterial arbon Steel - ISI/SE 1214 Stainless Steel - Type 316 Plating - Zinc, yellow dichromate. 274 End Size 1/8" 3/16" 1/4" 5/16" 3/8" 1/2" 5/8" 3/4" 7/8" 1" 1-1/4" 1-1/2" 2" SE Fittings W/djustable Straight Thread O-Ring With ale Pipe With Female Pipe Brazed dapters (TF)/SE 5000 Series Pressure Rating hart onnection Type End Size 1/8" 3/16" 1/4" 5/16" 3/8" 1/2" 5/8" 3/4" 7/8" 1" 1-1/4" 1-1/2" 2" SE Fittings W/djustable Straight Thread O-Ring 5000 With ale or Female Pipe Used With opper, brass, steel, aluminum and other tubing that can be flared. See page for material compatibility. dvantages Zinc Plate. hoice of two or three-piece design. Broad selection of styles and sizes. Interchangeable with all sources. onformance eets specifications and standards of S, SE and SE. How to Order To order a three-piece assembly, prefix the catalog number with a 3. Example: To order a male connector 5205x4 with nut and sleeve assembled, order 35205x4. To order a two-piece assembly, order nut and body separately. Example: Order male connector 5205x4 and twopiece style nut 5115x4. Bodies, nuts and sleeves can be ordered separately by catalog number. Stainless steel bodies, nuts and sleeves are ordered separately by catalog number. To order Weathercote finish (black phosphate coating) use W prefix in place of. Example: W5205x4 (special order only). To order with pipe sealants (Seal-Thread), add a Z suffix to the catalog number. Example: 5205x4Z (special order only). OTE Refer to current price list for availability of cataloged items. Quotations and delivery of non-stock items supplied on request. onfigurations and dimensions subject to change without notice. dditional information can be found in SE J514. Weatherhead fittings with a prefix are made from a forged construction. Example: 5405x4. Weatherhead fittings with a TF prefix are made from a brazed construction. Example:TF5405x4. abel Set: FS-200 (adhesive) ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006 ssembly Instructions 1. ut tubing to desired length. ake sure all burrs are removed and ends are cut square. 2. Slide nut on tube. Threaded end of nut must face toward fitting body. (See above.) 3. Slide sleeve on tube (3- piece assembly only). ollar end B of sleeve must face toward fitting body. (See above.) 4. Flare end of tubing with 37 flaring tool. a. heck flare diameter. For dimensional data on 37 flares, see page 275. b. Examine flare for excessive thinout. c. On thin wall, welded or brazed tubing, use double flare to prevent pinch-off and cracked flares. 5. ubricate threads and assemble to fitting body. ut should be turned hand tight. 6. Tighten assembly until finger tight, then until a sharp torque rise is encountered. From that point, apply onesixth turn with a wrench.

34 JI 37 Flare-Twin imensional ata imensional ata Two-Piece ssemblies imensional ata Three-Piece ssemblies ote: H & H1 are dimensions of fittings assembled to hand tight condition. Straight Thread O-Ring Thread Sizes Straight Thread B1 H H1 Tube O.. h h1 1/8.31 3/ / / / / / /4.61 7/ / / Port Thread Port Thread Size size B1 size size B1 1/8 5/ /4 1-1/ /16 3/8 24 7/8 1-3/ /4 7/ / /16 1/ /4 1-5/8 12 3/8 9/ /2 1-7/8 12 1/2 3/ /2 12 5/8 7/8 14 PPITIO T SPEITY HOSE HIGH OW & EIU Straight Thread O-Ring Fitting djustable Fittings Permit exact positioning of tees and elbows. Provide a leakproof joint. Eliminate distorted bosses from over tightening. 1. ubricate O-ring by coating with a light oil or petrolatum and push back-up washer and O- ring to the extreme rear of the O-ring groove. 2. Turn the lock nut down until it just contacts the back-up washer. 3. Screw fitting by hand into straight thread boss until the back-up washer contacts the face of the boss. 4. Position the fitting by backing out (counterclockwise) up to one full turn. Hold fitting in desired position and tighten lock nut with a wrench. 5. ssemble tube to fitting. Retighten lock nut. OTE: O-ring, lock nuts and back-up washers are preassembledon all straight thread fittings. ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES Swivel Fitting (Used with onnector) Weatherhead swivel end fittings can be used with a straight connector when space limitations will not permit full rotation of standard straight thread elbows and tees. 1. Screw connector into the O-ring boss and tighten. 2. Thread swivel nut onto connector. 3. Hold fitting in desired position and tighten swivel nut with a wrench ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

35 PPITIO T JI 37 Flare-Twin vailable in Stainless Steel. OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS Sleeve 3 Piece Stainless Steel o. 5177x (Ref. SE o ) 33 Sleeve 3 Piece etric (Ref. SE o ) 33 Tube atalog d l O.. umber 1/8 5165x / x /4 5165x / x /8 5165x /2 5165x /8 5165x /4 5165x /8 5165x x /4 5165x /2 5165x x Tube Tube atalog d l O.. O.. umber (Inch Size) (etric Size) 1/ x4x / x5x / x6x / x8x / x10x / x10x / x10x / x12x / x14x / x14x x16x / x20x / x20x / x24x dapts Standard SE Flare-Twin Hose Ends for use with metric tubing. PTERS & HOSE ES HOSE SSEBY JI 37 Braze dapter B 37º T Part o (ash Size) ash TuBE Thread Size O.. T B mm inches mm inches mm inches mm inches 4S 6, / ,8.74 6,3.25 4,0.16 5S 7, / ,3.80 7,9.31 4,0.16 6S 9, / ,6.81 9,6.38 4,0.16 8S 12, / , ,7.50 4, S 16, / , ,7.62 4, S 19, / , ,0.75 6, S 25, / , , , S 31, / , , , S 31, / , , , S 50, / , , ,3.25 TEHI T 276 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

36 JI 37 Flare-Twin ut 3 Piece Stainless Steel o. 5117x (Ref. SE o ) SE style 'B' 2 Piece ut (Short) Tube atalog Hex d l O.. umber 1/8 5105x2 3/ / x3 7/ /4 5105x4 9/ / x5 5/ /8 5105x6 11/ /2 5105x8 7/ /8 5105x /4 5105x12 1-1/ /8 5105x14 1-3/ x16 1-1/ /4 5105x /2 5105x24 2-1/ x32 2-7/ Tube atalog Hex d l O.. umber 1/4 5125x4 9/ / x5 5/ /8 5125x6 11/ /2 5125x8 7/ /8 5125x /4 5125x12 1-1/ vailable in Stainless Steel. PPITIO T SPEITY HOSE HIGH OW & EIU 2 Piece ut (Ref. SE o (style )) Bulkhead ut Stainless Steel o. 7936x (Ref. SE o ) Tube atalog Hex d l O.. umber 1/4 5115x4 9/ / x5 5/ /8 5115x6 11/ /2 5115x8 7/ /8 5115x /4 5115x12 1-1/ /8 5115x14 1-3/ x16 1-1/ /4 5115x /2 5115x24 2-1/ Tube atalog Hex l O.. umber 1/8 5924x2 9/ / x3 5/8.22 1/4 5924x4 11/ / x5 3/4.28 3/8 5924x6 13/ /2 5924x /8 5924x10 1-1/8.36 3/4 5924x12 1-3/8.41 7/8 5924x14 1-1/ x16 1-5/ /4 5924x20 1-7/ /2 5924x24 2-1/ x32 2-3/4.41 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

37 PPITIO T JI 37 Flare-Twin vailable in Stainless Steel. OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY TEHI T ap Stainless Steel o. 5141x (Ref. SE o ) Plug Stainless Steel o. 5241x (Ref. SE o ) Reducer 278 B (*one-piece design) 1 Steel Hose Ends Stainless Steel o. 5027x (Ref. SE o ) Example assembly o x X 37 Tube atalog Hex l O.. umber 1/8 5129x2 3/8.50 3/ x3 7/ /4 5129x4 9/ / x5 5/8.61 3/8 5129x6 11/ /2 5129x8 7/8.75 5/8 5129x /4 5129x12 1-1/ x16 1-1/ /4 5129x /2 5129x24 2-1/ x32 2-7/ Tube atalog Hex l d1 O.. umber Opt. 1/4 5229x4 1/ / x5 9/ /8 5229x6 5/ /2 5229x8 13/ /8 5229x10 15/ /4 5229x12 1-1/ /8 5229x14 1-1/ x16 1-3/ /4 5229x / /2 5229x x32 2-5/ Female ale atalog d l dia. hex Reduction Reduction umber x B 3/8 1/4 5015x6x /2 1/4 5015x8x /2 3/8 5015x8x /8* 1/4 5015x10x /8* 3/8 5015x10x /8* 1/2 5015x10x /4 1/4 5015x12x /4 3/8 5015x12x /4 1/2 5015x12x /4* 5/8 5015x12x /4 7/8* 3/8 5015x14x /8 7/8* 1/2 5015x14x /8 7/8* 5/8 5015x14x /8 7/8* 3/4 5015x14x /8 1* 1/2 5015x16x /2 1* 5/8 5015x16x /2 1 3/4 5015x16x * 7/8 5015x16x /2 1-1/4 3/4 5015x20x /4* x20x /2* 1-1/4 5015x24x /4 2* 1-1/2 5015x32x /8 OTE: Two-piece design does not include nut. Order nut 5105x to use reducer. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

38 JI 37 Flare-Twin vailable in Stainless Steel. PPITIO T Reducer (Ref. SE ) 37º Small Hex Union Stainless Steel o. 5317x (Ref. SE o ) Example assembly o x2 T 1 T 2 37º 1 Part o (ash Size) ash Tube Thread Thread Size O.. T1 T2 mm inches mm inches 10-6S 9, / / , S 9, / / , S 12, / / , S 16, / / , S 19, / / , S 25, / / , Includes swivel nut Tube Tube atalog Hex d d1 l O.. O.. umber 1/8 1/8 5305x2 7/ /16 3/ x3 7/ /4 1/4 5305x4 1/ /16 1/4 5305x5x4 9/ /16 5/ x5 9/ /8 1/4 5305x6x4 5/ /8 5/ x6x5 5/ /8 3/8 5305x6 5/ /2 3/8 5305x8x6 13/ /2 1/2 5305x8 13/ /8 1/2 5305x10x8 15/ /8 5/8 5305x10 15/ /4 1/2 5305x12x8 1-1/ /4 5/8 5305x12x10 1-1/ /4 3/4 5305x12 1-1/ /8 7/8 5305x14 1-1/ /4 5305x16x12 1-3/ x16 1-3/ /4 1-1/4 5305x / /2 1-1/2 5305x x32 2-5/ SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

39 PPITIO T JI 37 Flare-Twin vailable in Stainless Steel. OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS arge Hex Union Stainless Steel o. 5318x (Ref. SE o ) Example assembly o x2 Bulkhead Union Stainless Steel o. 5337x (Ref. SE o ) Example assembly o x4 I 1 Tube atalog Hex d d1 l O.. umber 1/4 5306x4 11/ / x5 3/ /8 5318x6x4* 13/ /8 5306x6 13/ /2 5318x8x6* /2 5306x /8 5306x10 1-1/ /4 5306x12 1-3/ x16 1-5/ /4 5306x20 1-7/ /2 5306x24 2-1/ * Stainless Steel Tube atalog Hex d i l O.. umber 3/ x3 5/ /4 5325x4 11/ / x5 3/ /8 5325x6 13/ /2 5325x /8 5325x10 1-1/ /4 5325x12 1-3/ x16 1-5/ /4 5325x20 1-7/ Bulkhead nut not included. ust be ordered separately. See page 277 for bulkhead nut. PTERS & HOSE ES HOSE SSEBY TEHI T 280 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

40 JI 37 Flare-Twin ale onnector Stainless Steel o. 5217x (Ref. SE o ) Example assembly o x4 *Optional counterbore for 1. ale onnector ong 1 ale onnector Extra ong P P T T 37º 37º Tube ale Pipe atalog hex 1 O.. Thread umber Opt. 1/8 1/8 5205x2 7/ * /16 1/8 5205x3 7/ * /4 1/8 5205x4 1/ * /4 1/4 5205x4x4 9/ * /4 3/8 5205x4x6 3/ * /4 1/2 5205x4x8 7/ * /16 1/8 5205x5 9/ /16 1/4 5205x5x4 5/ * /16 3/8 5205x5x6 13/ * /8 1/8 5205x6x2 5/ /8 1/4 5205x6 5/ /8 3/8 5205x6x6 3/ * /8 1/2 5205x6x8 7/ * /2 1/4 5205x8x4 13/ /2 3/8 5205x8 13/ * /2 1/2 5205x8x8 15/ * /2 3/4 5205x8x12 1-1/ * /8 3/8 5205x10x6 15/ /8 1/2 5205x10 15/ * /8 3/4 5205x10x12 1-1/ * /4 1/2 5205x12x8 1-1/ /4 3/4 5205x12 1-1/ * / x12x16 1-3/ * /8 3/4 5205x14 1-1/ * /4 5205x16x12 1-3/ x16 1-3/ * /4 5205x16x / * / x20x / /4 1-1/4 5205x / * /2 1-1/4 5205x24x * /2 1-1/2 5205x * x32 2-5/ * 3.11 Part o (ash Size) ash Tube Thread Thread Size O.. P T (nptf) a mm inches mm inches 2-4S 6, / / , S 6, / / , S 7, / / , S 9, / / , S 9, / / , S 12, / / , S 19, / / , S 19, / / , S 25, / / , Part o (ash Size) ash Tube Thread Thread Size O.. P T (nptf) a mm inches mm inches 2-4S 6, / / , S 6, / / , S 9, / / , S 12, / / , S 19, / / , vailable in Stainless Steel. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PPITIO T SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

41 PPITIO T OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS JI 37 Flare-Twin Female onnector Stainless Steel o. 5267x (Ref. SE o ) Example assembly o x4 Female Bulkhead onnector Example assembly o x4 I Tube Fem. pipe atalog hex O.. thread umber 1/8 1/8 5255x2 9/ /16 1/8 5255x3 9/ /4 1/8 5255x4 9/ /4 1/4 5255x4x4 3/ /16 1/8 5255x5 9/ /16 1/4 5255x5x4 3/ /8 1/4 5255x6 3/ /8 3/8 5255x6x6 7/ /2 3/8 5255x8 7/ /2 1/2 5255x8x8 1-1/ /8 3/8 5255x10x6 7/ /8 1/2 5255x10 1-1/ /4 1/2 5255x12x8 1-1/ /4 3/4 5255x12 1-3/ /8 3/4 5255x14 1-3/ x16 1-5/ /4 1-1/4 5255x /2 1-1/2 5255x24 2-3/ x32 2-7/ Tube Fem. atalog Hex I O.. Pipe umber Thread 1/4 1/8 5275x4 11/ /8 1/4 5275x6 13/ /2 3/8 5275x /8 1/2 5275x10 1-1/ /4 3/4 5275x12 1-3/ x16 1-5/ Bulkhead nut not included. ust be ordered separately. See page 277 for bulkhead nut. PTERS & HOSE ES ale Bulkhead onnector Part o (ash Size) ash Tube Thread Thread Size O.. P (nptf) T HOSE SSEBY P T 37º mm inches mm inches 2-4S 6, / / , S 6, / / , S 9, / / , S 12, / / , S 19, / / , S 25, / / , TEHI T 282 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

42 JI 37 Flare-Twin PPITIO T ale JI 37 SE to Female For-Seal 1 1 Straight Thread O-Ring Extended onnector (Ref. SE o ) Example assembly o x4 Female ale Tube 37 Tube atalog Hex Hex 1 O.. Size umber 1 1/4 1/4 4213x4 11/16 5/ /8 3/8 4213x6 13/16 3/ /2 1/2 4213x8 15/16 7/ /8 5/8 4213x10 1-1/8 1-1/ /4 3/4 4213x12 1-3/16 1-1/ x16 1-5/8 1-1/ Tube Port atalog Hex I O.. Size umber 1/4 1/4 5316x4 9/ /8 3/8 5316x6 11/ /2 3/8 5316x8x6 7/ /2 1/2 5316x8 7/ /8 5/8 5316x /4 3/4 5316x12 1-1/ x16 1-1/ /4 1-1/4 5316x20 1-7/ SPEITY HOSE HIGH OW & EIU I Replacement O-rings page 302. ESSORRIES & S BY ISTRUTIOS dapter Example assembly o x4 Tube Inverted atalog Hex O.. Thread umber 1/4 7/ x4 1/ /16 1/ x5 9/ /8 5/ x6 11/ /2 3/ x8 13/ PTERS & TUBE HOSE ES Inverted Thread ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

43 PPITIO T JI 37 Flare-Twin vailable in Stainless Steel. OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES Straight Thread O-Ring onnector Stainless Steel o. 5327x (Ref. SE o ) Example assembly o x4 I *Optional counterbore for 1. Replacement O-rings page Tube Port atalog Hex 1 I O.. Size umber Opt. 1/8 1/8 5315x2 7/ * /16 3/ x3 1/ * /4 1/4 5315x4 9/ * /4 5/ x4x5 5/ * /4 3/8 5315x4x6 11/ * /4 1/2 5315x4x8 7/ * /16 1/4 5315x5x4 5/ /16 5/ x5 5/ * /16 3/8 5315x5x6 11/ * /8 1/4 5315x6x4 11/ /8 5/ x6x5 11/ /8 3/8 5315x6 11/ * /8 1/2 5315x6x8 7/ * /8 5/8 5315x6x * /2 3/8 5315x8x6 13/ /2 1/2 5315x8 7/ * /2 5/8 5315x8x * /2 3/4 5315x8x12 1-1/ * /8 1/2 5315x10x /8 5/8 5315x * /8 3/4 5315x10x12 1-1/ * / x10x16 1-1/ * /4 1/2 5315x12x8 1-1/ /4 5/8 5315x12x10 1-1/ /4 3/4 5315x12 1-1/ * /4 7/8 5315x12x14 1-3/ * / x12x16 1-1/ * /4 1-1/4 5315x12x20 1-7/ * /8 7/8 5315x14 1-3/ * /8 5315x16x10 1-1/ /4 5315x16x12 1-1/ x16 1-1/ * /4 5315x16x20 1-7/ * / x20x16 1-7/ /4 1-1/4 5315x20 1-7/ * /4 1-1/2 5315x20x24 2-1/ * /2 1-1/4 5315x24x20 2-1/ * /2 1-1/2 5315x24 2-1/ * / x24x32 2-3/ * /2 5315x32x24 2-3/ * x32 2-3/ HOSE SSEBY Female JI 37 Swivel to Female Pipe Tube Female atalog Hex Hex O.. Pipe umber 1 1/4 1/4 5256x4x4 9/16 3/ /8 3/8 5256x6x6 11/16 7/ /2 1/2 5256x8x8 7/8 1-1/ /4 3/4 5256x12 1-1/4 1-1/ x16 1-1/2 1-1/ TEHI T ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

44 JI 37 Flare-Twin vailable in Stainless Steel. PPITIO T Female JI 37 Swivel to ale Pipe dapter 1 ale JI 37 to ale etric Standpipe *Optional counterbore for 1. For metric flareless nuts and sleeves see page Tube ale pipe atalog Hex Hex 1 O.. size umber 1 1/4 1/4 9100x4x4 9/16 9/ * /16 1/4 9100x5x4 11/16 5/ * /8 1/4 9100x6x4 11/16 11/ /8 3/8 9100x6x6 11/16 11/ * /2 3/8 9100x8x6 7/8 7/ * /2 1/2 9100x8x8 7/8 7/ * /8 3/8 9100x10x /8 1/2 9100x10x * /4 1/2 9100x12x8 1-1/8 1-1/ /4 3/4 9100x12x12 1-1/8 1-1/ * /4 9100x16x12 1-3/8 1-1/ x16x16 1-3/8 1-1/ * /4 1-1/4 9100x20x20 1-7/ * 2.73 Tube Tube atalog Hex O.. O.. (mm) umber 1/ x4x6 9/ / x4x8 9/ / x6x10 3/ / x8x12 7/ / x8x14 7/ / x10x / x10x / x12x16 1-1/ / x12x18 1-1/ / x12x20 1-1/ x16x22 1-1/ x16x25 1-1/ SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS ale JI 37 to O-Ring Port dapter -Thread B-Thread Tube Port atalog Replacement Thread Thread Hex Size Size umber O-Ring B 1/4 1/ x4 7629x1 7/ / / /8 3/ x6 7629x3 9/ /8-18 5/ /2 1/ x8 7629x5 3/4-16 3/4-16 3/ /8 5/ x x7 7/8-14 7/ / /4 3/ x x8 1-1/ / / ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

45 PPITIO T JI 37 Flare-Twin vailable in Stainless Steel. OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY 45 ale Elbow Stainless Steel o. 5367x (Ref. SE o ) Example assembly o x Tube ale Pipe atalog 1 cross O.. Thread umber Flats 1/8 1/8 5355x /16 3/16 1/8 5355x /16 1/4 1/8 5355x /16 1/4 1/4 5355x4x /16 5/16 1/8 5355x /16 5/16 1/4 5355x5x /16 3/8 1/8 5355x6x /16 3/8 1/4 5355x /16 3/8 3/8 5355x6x /4 3/8 1/2 5355x6x /8 1/2 1/4 5355x8x /4 1/2 3/8 5355x /4 1/2 1/2 5355x8x /8 5/8 3/8 5355x10x /8 5/8 1/2 5355x /8 3/4 1/2 5355x12x /16 3/4 3/4 5355x /16 1 3/4 5355x16x / x /16 1-1/2 1-1/2 5355x /8 1/8 1/8 TF5355x /16 1/4 1/8 TF5355x /2 1/4 1/4 TF5355x4x /8 5/16 1/8 TF5355x /16 5/16 1/4 TF5355x5x /8 3/8 1/8 TF5355x6x /8 3/8 1/4 TF5355x /8 3/8 3/8 TF5355x6x /16 3/8 1/2 TF5355x6x /16 1/2 1/4 TF5355x8x /16 1/2 3/8 TF5355x /16 1/2 1/2 TF5355x8x /16 5/8 3/8 TF5355x10x /16 5/8 1/2 TF5355x /16 5/8 3/4 TF5355x10x /8 3/4 1/2 TF5355x12x /8 3/4 3/4 TF5355x /8 3/4 1 TF5355x12x /8 1 3/4 TF5355x16x /8 1 1 TF5355x /8 1-1/4 1-1/4 TF5355x /4 1-1/2 1-1/2 TF5355x TF5355x /8 TEHI T 286 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

46 JI 37 Flare-Twin PPITIO T 37 JI Female Swivel to ale Straight Thread O-Ring 45 Elbow - Swivel ut 1 Stainless Steel o. 5368x (Ref. SE o ) Example assembly o x4 45 Tube Port atalog Hex Hex O.. Size umber 1 1/4 1/4 5216x4x4 9/16 9/ /4 3/8 5216x4x6 11/16 11/ /8 3/8 5216x6x6 11/16 11/ /8 1/2 5216x6x8 11/16 7/ /2 3/8 5216x8x6 7/8 3/ /2 1/2 5216x8x8 7/8 7/ /8 5/8 5216x10x /4 3/4 5216x12x12 1-1/4 1-1/ x16x16 1-1/2 1-1/ /4 1-1/4 5216x20x / /2 1-1/2 5216x24x24 2-1/8 2-1/ x32x32 2-3/4 2-3/ For replacement Straight Thread O-rings, see page 302. Tube atalog hex cross O.. umber flats 1/4 5356x4 9/ /16 5/ x5 5/ /16 3/8 5356x6 11/ /16 1/2 5356x8 7/ /4 5/8 5356x /8 3/4 5356x12 1-1/ /16 7/8 5356x14 1-3/ / x16 1-1/ /16 1-1/2 5356x24 2-1/ /8 1/4 TF5356x4 9/ /2 5/16 TF5356x5 5/ /16 3/8 TF5356x6 11/ /8 1/2 TF5356x8 7/ /16 5/8 TF5356x /16 3/4 TF5356x12 1-1/ /8 1 TF5356x16 1-1/ /8 1-1/4 TF5356x /4 1-1/2 TF5356x24 2-1/ TF5356x32 2-7/ /8 SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

47 PPITIO T JI 37 Flare-Twin OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY 45 Bulkhead Union Elbow (Ref. SE o ) 45 I 1 45 Elbow - Straight Thread O-Ring (Ref. SE o ) Example assembly o x4 45 Replacement O-rings page TuBE atalog 1 cross I O.. umber flats 1/4 TF5375x / /16 TF5375x / /8 TF5375x / /2 TF5375x / /8 TF5375x / /4 TF5375x / TF5375x / Bulkhead nut not included. ust be ordered separately. See page 277 for bulkhead nut. Tube Port atalog 1 cross O.. Size umber flats 1/4 1/4 5365x /16 5/16 5/ x /16 3/8 3/8 5365x /16 1/2 1/2 5365x /4 1/2 5/8 5365x8x /8 5/8 5/8 5365x /8 3/4 5/8 5365x12x /16 3/4 3/4 5365x / x /16 1-1/4 1-1/4 5365x /8 1/4 1/4 TF5365x /2 5/16 5/16 TF5365x /16 3/8 3/8 TF5365x /8 3/8 1/2 TF5365x6x /16 1/2 3/8 TF5365x8x /16 1/2 1/2 TF5365x /16 1/2 5/8 TF5365x8x /16 5/8 1/2 TF5365x10x /16 5/8 5/8 TF5365x /16 5/8 3/4 TF5365x10x /8 3/4 5/8 TF5365x12x /8 3/4 3/4 TF5365x /8 3/4 1 TF5365x12x /8 7/8 7/8 TF5365x /4 1 3/4 TF5365x16x /8 1 1 TF5365x /8 1-1/4 1-1/4 TF5365x /4 1-1/2 1-1/2 TF5365x TF5365x /8 TEHI T 288 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

48 JI 37 Flare-Twin 90 Union Elbow Stainless Steel o. 5517x (Ref. SE o ) Example assembly o x4 TuBE atalog d m cross O.. umber flats 1/4 5505x /16 3/8 5505x /16 1/2 5505x /4 5/8 5505x /8 3/4 5505x / x /16 1/4 TF5505x /2 5/16 TF5505x /2 3/8 TF5505x /8 1/2 TF5505x /16 5/8 TF5505x /16 3/4 TF5505x /8 7/8 TF5505x /4 1 TF5505x /8 1-1/4 TF5505x /4 1-1/2 TF5505x TF5505x /8 vailable in Stainless Steel. PPITIO T SPEITY HOSE HIGH OW & EIU 90 ale Elbow ong (Ref. SE o ) Example assembly o x4 1 Tube ale atalog 1 cross O.. Pipe umber flats Thread 3/8 1/4 5425x /16 3/4 3/4 5425x /16 1/4 1/8 TF5425x /2 1/4 1/4 TF5425x4x /8 5/16 1/4 TF5425x5x /16 3/8 1/4 TF5425x /8 3/8 3/8 TF5425x6x /16 1/2 3/8 TF5425x /16 1/2 1/2 TF5425x8x /16 1/2 3/4 TF5425x8x /8 5/8 1/2 TF5425x /16 3/4 3/4 TF5425x /8 7/8 3/4 TF5425x /4 1 1 TF5425x /8 1-1/4 1-1/4 TF5425x /4 1-1/2 1-1/2 TF5425x ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

49 PPITIO T OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY TEHI T JI 37 Flare-Twin 90 ale Elbow Stainless Steel o. 5417x (Ref. SE o ) Example assembly o x4 290 vailable in Stainless Steel. 1 Tube ale pipe atalog d d1 cross O.. thread umber flats 1/8 1/8 5405x /16 3/16 1/8 5405x /16 1/4 1/8 5405x /16 1/4 1/4 5405x4x /16 5/16 1/8 5405x /16 5/16 1/4 5405x5x /16 3/8 1/8 5405x6x /16 3/8 1/4 5405x /16 3/8 3/8 5405x6x /4 3/8 1/2 5405x6x /8 1/2 1/4 5405x8x /4 1/2 3/8 5405x /4 1/2 1/2 5405x8x /8 1/2 3/4 5405x8x /16 5/8 3/8 5405x10x /8 5/8 1/2 5405x /8 5/8 3/4 5405x10x /16 3/4 1/2 5405x12x /16 3/4 3/4 5405x /16 1 3/4 5405x16x / x /16 1-1/ x20x /8 1-1/4 1-1/4 5405x /8 1-1/2 1-1/2 5405x / x /16 1/4 1/8 TF5405x /2 1/4 1/4 TF5405x4x /8 1/4 3/8 TF5405x4x /16 1/4 1/2 TF5405x4x /16 5/16 1/8 TF5405x /16 5/16 1/4 TF5405x5x /8 5/16 3/8 TF5405x5x /16 3/8 1/8 TF5405x6x /8 3/8 1/4 TF5405x /8 3/8 3/8 TF5405x6x /16 3/8 1/2 TF5405x6x /16 3/8 3/4 TF5405x6x /8 1/2 1/4 TF5405x8x /16 1/2 3/8 TF5405x /16 1/2 1/2 TF5405x8x /16 1/2 3/4 TF5405x8x /8 5/8 3/8 TF5405x10x /16 5/8 1/2 TF5405x /16 5/8 3/4 TF5405x10x /8 3/4 1/2 TF5405x12x /8 3/4 3/4 TF5405x /8 3/4 1 TF5405x12x /8 7/8 3/4 TF5405x /4 1 3/4 TF5405x16x /8 1 1 TF5405x / /4 TF5405x16x /4 1-1/4 1 TF5405x20x /4 1-1/4 1-1/4 TF5405x /4 1-1/4 1-1/2 TF5405x20x /2 1-1/4 TF5405x24x /2 1-1/2 TF5405x TF5405x /8 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

50 JI 37 Flare-Twin Tube ale atalog 1 cross 90 ale Elbow Extra ong (Ref. SE o ) 90 Swivel ale Elbow P T B 1 vailable in Stainless Steel. O.. Pipe umber flats Thread 1/4 1/8 TF5435x /2 1/4 1/4 TF5435x4x /8 5/16 1/8 TF5435x /16 5/16 1/4 TF5435x5x /16 3/8 1/4 TF5435x /8 3/8 3/8 TF5435x6x /16 1/2 3/8 TF5435x /16 1/2 1/2 TF5435x8x /16 5/8 1/2 TF5435x /16 3/4 3/4 TF5435x /8 7/8 3/4 TF5435x /4 1 1 TF5435x /8 1-1/4 1-1/4 TF5435x /4 Part o (ash Size) ash Tube Thread Thread Size O.. P (nptf) T B mm inches mm inches mm inches 4-6S 9, / / , , S 12, / / , , S 19, / / , , PPITIO T SPEITY HOSE HIGH OW & EIU 90 Bulkhead Union Elbow Stainless Steel o. 5537x (Ref. SE o ) Example assembly o x4 I 1 37º TuBE atalog I 1 cross O.. umber flats 1/4 5525x /16 3/8 5525x /16 1/2 5525x /4 3/4 5525x / x /16 1-1/4 5525x /8 1/4 TF5525x /2 5/16 TF5525x /16 3/8 TF5525x /8 1/2 TF5525x /16 5/8 TF5525x /16 3/4 TF5525x /8 1 TF5525x /8 Bulkhead nut not included. ust be ordered separately. See page 277 for bulkhead nut. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

51 PPITIO T OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY JI 37 Flare-Twin 90 Female Elbow Stainless Steel o. 5467x (Ref. SE o ) Example assembly o x4 90 Elbow - Swivel ut Stainless Steel o. 5518x (Ref. SE o ) Example assembly o x4 Tube Fem. pipe atalog cross O.. thread `umber flats 1/4 1/8 5455x /16 3/8 1/8 5455x6x /16 3/8 1/4 5455x /4 3/8 3/8 5455x6x /8 1/2 1/4 5455x8x /4 1/2 3/8 5455x /8 1/2 1/2 5455x8x /16 5/8 1/2 5455x /16 3/4 1/2 5455x12x /16 3/4 3/4 5455x /16 7/8 3/4 5455x / x /8 1/4 1/8 TF5455x /8 1/4 1/4 TF5455x4x /4 5/16 1/8 TF5455x /8 5/16 1/4 TF5455x5x /8 3/8 1/4 TF5455x /4 3/8 3/8 TF5455x6x /4 1/2 3/8 TF5455x /8 1/2 1/2 TF5455x8x /8 5/8 1/2 TF5455x /8 3/4 3/4 TF5455x /8 7/8 3/4 TF5455x /8 1 1 TF5455x /8 1-1/4 1-1/4 TF5455x /2 1-1/2 TF5455x /8 2 2 TF5455x /8 TuBE atalog Hex cross O.. umber flats 1/4 5506x4 9/ /16 5/ x5 5/ /16 3/8 5506x6 11/ /16 1/2 5506x8 7/ /4 5/8 5506x /8 3/4 5506x12 1-1/ / x16 1-1/ /16 1-1/4 5506x /8 1/4 TF5506x4 9/ /2 5/16 TF5506x5 5/ /16 3/8 TF5506x6 11/ /8 1/2 TF5506x8 7/ /16 5/8 TF5506x /16 3/4 TF5506x12 1-1/ /8 7/8 TF5506x14 1-3/ /4 1 TF5506x16 1-1/ /8 1-1/4 TF5506x /4 1-1/2 TF5506x24 2-1/ TF5506x32 2-7/ /8 vailable in Stainless Steel. TEHI T 292 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

52 JI 37 Flare-Twin PPITIO T 90 Sweep Elbow Part o (ash Size) T 1 T 2 37º 90 Sweep Elbow 37º T 1 T 2 37º 90 Sweep Elbow ong T 1 T 2 B 37º B B ash Tube Thread Thread Size O.. T1 T2 B mm inches mm inches mm inches 4S 6, / / , , S 9, / / , , S 12, / / , , S 16, / / , , S 19, / / , , S 25, / / , , S 31, / / , , (Suitable for pressures through 2-wire hose) Part o. FF5163- (ash Size) ash Tube Thread Thread Size O.. T1 T2 B mm inches mm inches mm inches 0808S 12, / / , , S 19, / / , , S 25, / / , , S 31, / / , , S 38, / / , , (Suitable for pressures through 4-wire hose) Part o (ash Size) ash Tube Thread Thread Size O.. T1 T2 B mm inches mm inches mm inches 4S 6, / / , , S 9, / / , , S 12, / / , , S 16, / / , , S 19, / / , , S 25, / / , , S 31, / / , , (Suitable for pressures through 2-wire hose) SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES 90 Sweep Elbow ong 37º T 1 T 2 37º B Part o. FF5164- (ash Size) ash Tube Thread Thread Size O.. T1 T2 B mm inches mm inches mm inches 0808S 12, / / , , S 19, / / , , S 25, / / , , (Suitable for pressures through 4-wire hose) ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

53 PPITIO T JI 37 Flare-Twin vailable in Stainless Steel. OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY 90 Elbow - Straight Thread O-Ring Stainless Steel o. 5527x (Ref. SE o ) Example assembly o x4 Replacement O-rings page Tube Port atalog 1 cross O.. Size umber flats 3/16 3/ x /16 1/4 1/4 5515x /16 5/16 5/ x /16 3/8 3/8 5515x /16 3/8 1/2 5515x6x /4 1/2 3/8 5515x8x /4 1/2 1/2 5515x /4 1/2 5/8 5515x8x /8 5/8 5/8 5515x /8 3/4 5/8 5515x12x /16 3/4 3/4 5515x /16 7/8 7/8 5515x /16 1 3/4 5515x16x / x /16 1-1/4 1-1/4 5515x /8 1-1/2 1-1/2 5515x /8 1/4 1/4 TF5515x /2 1/4 5/16 TF5515x4x /8 1/4 3/8 TF5515x4x /8 5/16 1/4 TF5515x5x /16 5/16 5/16 TF5515x /16 5/16 3/8 TF5515x5x /8 3/8 1/4 TF5515x6x /8 3/8 5/16 TF5515x6x /8 3/8 3/8 TF5515x /8 3/8 1/2 TF5515x6x /16 3/8 5/8 TF5515x6x /16 1/2 3/8 TF5515x8x /16 1/2 1/2 TF5515x /16 1/2 5/8 TF5515x8x /16 1/2 3/4 TF5515x8x /8 5/8 1/2 TF5515x10x /16 5/8 5/8 TF5515x /16 5/8 3/4 TF5515x10x /8 3/4 1/2 TF5515x12x /8 3/4 5/8 TF5515x12x /8 3/4 3/4 TF5515x /8 3/4 7/8 TF5515x12x /4 3/4 1 TF5515x12x /8 7/8 7/8 TF5515x /16 1 3/4 TF5515x16x /8 1 7/8 TF5515x16x /8 1 1 TF5515x / /4 TF5515x16x /4 1-1/4 1 TF5515x20x /4 1-1/4 1-1/4 TF5515x /4 1-1/2 1-1/4 TF5515x24x /2 1-1/2 TF5515x TF5515x /8 TEHI T 294 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

54 JI 37 Flare-Twin 90 Elbow ong - Straight Thread O-Ring (Ref. SE o ) 90 Elbow Extra ong - Straight Thread O-Ring (Ref. SE o ) Tube Port atalog 1 cross O.. Size umber flats 3/8 3/8 TF5515x /8 1/2 1/2 TF5515x /16 5/8 5/8 TF5515x /16 3/4 3/4 TF5515x /8 Replacement O-rings page Tube Port atalog 1 cross O.. Size umber flats 3/8 3/8 TF5515x /8 1/2 1/2 TF5515x /16 5/8 5/8 TF5515x /16 3/4 3/4 TF5515x /8 Replacement O-rings page 302. PPITIO T SPEITY HOSE HIGH OW & EIU 1 90 ale Pipe to 37 JI Swivel Tube ale atalog cross Hex O.. Pipe umber flats 1/4 1/8 TF5406x /2 9/16 3/8 1/4 TF5406x /8 11/16 1/2 3/8 TF5406x /16 7/8 5/8 1/2 TF5406x /16 1 3/4 3/4 TF5406x /8 1-1/4 1 1 TF5406x /8 1-1/2 1-1/4 1-1/4 TF5406x / /2 1-1/2 TF5406x /4 2 2 TF5406x /8 2-7/8 ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES 90 Female Pipe to 37 JI Swivel P T 37º B Part o (ash Size) ash Tube Thread Thread Size O.. P (nptf) T B mm inches mm inches mm inches 8-8S 12, / / , , S 16, / / , , ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

55 PPITIO T OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY JI 37 Flare-Twin Union Tee Stainless Steel o. 5717x (Ref. SE o ) ssembly o x4 ale Run Tee 1 Stainless Steel o. 5767x (Ref. SE o ) Example asembly o x4 B B 2 B vailable in Stainless Steel. Tube Tube Tube atalog 1 2 cross O.. O.. O.. umber flats B 1/8 1/8 1/8 5705x /16 3/16 3/16 3/ x /16 1/4 1/4 1/4 5705x /16 5/16 5/16 5/ x /16 3/8 3/8 3/8 5705x /16 1/2 1/2 1/2 5705x /4 5/8 5/8 5/8 5705x /8 3/4 3/4 3/4 5705x /16 7/8 7/8 7/8 5705x / x /16 1-1/4 1-1/4 1-1/4 5705x /8 1-1/2 1-1/2 1-1/2 5705x /8 1/4 1/4 1/4 TF5705x /2 5/16 5/16 5/16 TF5705x /2 3/8 3/8 3/8 TF5705x /8 1/2 1/2 1/2 TF5705x /16 5/8 1/2 1/2 TF5705x10x8x /16 5/8 5/8 5/8 TF5705x /16 5/8 5/8 1/2 TF5705x10x10x /16 3/4 3/4 3/4 TF5705x /8 7/8 7/8 7/8 TF5705x / TF5705x /8 1-1/4 1-1/4 1-1/4 TF5705x /4 1-1/2 1-1/2 1-1/2 TF5705x / TF5705x /8 Tube ale Pipe atalog 1 cross O.. Thread umber flats 1/4 1/8 5755x /16 1/2 3/8 5755x /4 5/8 1/2 5755x /8 3/4 3/4 5755x / x /16 1/4 1/8 TF5755x /2 1/4 1/4 TF5755x4x4x /16 5/16 1/8 TF5755x /2 3/8 1/4 TF5755x /16 3/8 3/8 TF5755x6x6x /16 1/2 3/8 TF5755x /16 1/2 1/2 TF5755x8x8x /8 5/8 1/2 TF5755x /16 3/4 3/4 TF5755x /8 7/8 3/4 TF5755x /4 1 1 TF5755x /8 1-1/4 1-1/4 TF5755x /4 1-1/2 1-1/2 TF5755x TF5755x /8 TEHI T ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

56 JI 37 Flare-Twin vailable in Stainless Steel. PPITIO T Female Run Tee (Ref. SE o ) ale Pipe/Female Pipe/37 Flare Tee P T B P Tube Fem. Pipe atalog cross O.. Thread umber flats 1/4 1/8 TF5805x /8 3/8 1/4 TF5805x /4 1/2 3/8 TF5805x /8 5/8 1/2 TF5805x /8 3/4 3/4 TF5805x /8 7/8 3/4 TF5805x /8 1 1 TF5805x /8 Part o (ash Size) ash Tube Thread Thread Size O.. P (nptf) T B mm inches mm inches mm inches mm inches 2-4S 6, / / , , , S 9, / / , , , S 19, / / , , , S 25, / / , , , SPEITY HOSE HIGH OW & EIU 37º ale Pipe/ 37 Flare/Female Pipe B P T 37º Part o (ash Size) ash Tube Thread Thread Size O.. P (nptf) T B mm inches mm inches mm inches mm inches 2-4S 6, / / , , , S 9, / / , , , S 9, / / , , , S 12, / / , , , S 16, / / , , , S 19, / / , , , ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES ale Pipe/Female Pipe 37 Flare Tee Part o (ash Size) ash Tube Thread Thread Size O.. P T B mm inches mm inches mm inches mm inches 12-12S 19,0.75 3/ / , , , ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

57 PPITIO T JI 37 Flare-Twin vailable in Stainless Steel. ale JI Run Tee Part o (ash Size) OW & EIU (Ref. SE ) B P T 37º ash Tube Thread Thread Size O.. P T B mm inches mm inches mm inches mm inches 4-6S 9, / / , , ,3.88 HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS Swivel ut Run Tee Stainless Steel o. 5718x (Ref. SE o ) Example assembly o x4 Tube atalog Hex cross O.. umber flats 1/4 5706x4 9/ /16 5/ x5 5/ /16 3/8 5706x6 11/ /16 1/2 5706x8 7/ /4 5/8 5706x /8 3/4 5706x12 1-1/ / x16 1-1/ /16 1-1/4 5706x /8 1/4 TF5706x4 9/ /2 5/16 TF5706x5 5/ /16 3/8 TF5706x6 11/ /8 1/2 TF5706x8 7/ /16 5/8 TF5706x /16 3/4 TF5706x12 1-1/ /8 7/8 TF5706x14 1-3/ /4 1 TF5706x16 1-1/ /8 1-1/4 TF5706x /4 1-1/2 TF5706x24 2-1/ TF5706x32 2-7/ /8 PTERS & HOSE ES Bulkhead Run Tee (Ref. SE o ) Example assembly o x6 Tube atalog I 1 cross O.. umber flats 3/8 5726x /16 1/2 TF5726x /4 Bulkhead nut not included. ust be ordered separately. See page 277 for bulkhead nut. HOSE SSEBY TEHI T 298 I 1 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

58 JI 37 Flare-Twin vailable in Stainless Steel. PPITIO T Straight Thread O-Ring Run Tee (Ref. SE o ) Example assembly o x4 1 Tube Port atalog 1 cross O.. Size umber flats 1/4 1/4 5716x / /16 5/ x / /8 3/8 5716x / /2 1/2 5716x / /8 5/8 5716x / /4 3/4 5716x / x / /4 1-1/4 5716x / /4 1/4 TF5716x /2.89 5/16 5/16 TF5716x / /8 3/8 TF5716x / /2 1/2 TF5716x / /8 5/8 TF5716x / /4 3/4 TF5716x / /8 7/8 TF5716x / TF5716x / /4 1-1/4 TF5716x / /2 1-1/2 TF5716x Replacement O-rings page 302. SPEITY HOSE HIGH OW & EIU ale Branch Tee Stainless Steel o. 5617x (Ref. SE o ) Example assembly o x4 1 Tube ale Pipe atalog 1 cross O.. Thread umber flats 1/4 1/8 5605x /16 1/4 1/4 5605x4x4x /16 5/16 1/8 5605x /16 3/8 1/4 5605x /16 1/2 3/8 5605x /4 5/8 1/2 5605x /8 3/4 3/4 5605x / x /16 1/4 1/8 TF5605x /2 1/4 1/4 TF5605x4x4x /8 5/16 1/8 TF5605x /16 3/8 1/4 TF5605x /8 3/8 3/8 TF5605x6x6x /16 1/2 3/8 TF5605x /16 1/2 1/2 TF5605x8x8x /16 5/8 1/2 TF5605x /16 3/4 3/4 TF5605x /8 7/8 3/4 TF5605x /4 1 1 TF5605x /8 1-1/4 1-1/4 TF5605x /4 1-1/2 1-1/2 TF5605x TF5605x /8 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

59 PPITIO T OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES JI 37 Flare-Twin Female Branch Tee Stainless Seel o. 5667x (Ref. SE o ) Example assembly o x4 Swivel ut Branch Tee Stainless Steel o. 5719x (Ref. SE o ) Example assembly o x4 Tube Fem. Pipe atalog cross O.. Thread umber flats 1/4 1/8 5655x /16 3/8 1/4 5655x /4 1/2 3/8 5655x /8 5/8 1/2 5655x /16 3/4 3/4 5655x /16 1/4 1/8 TF5655x /8 1/4 1/4 TF5655x4x4x /4 5/16 1/8 TF5655x /8 3/8 1/4 TF5655x /4 3/8 3/8 TF5655x6x6x /8 1/2 3/8 TF5655x /8 1/2 1/2 TF5655x8x8x /8 5/8 1/2 TF5655x /8 3/4 3/4 TF5655x /8 7/8 3/4 TF5655x /8 1 1 TF5655x /8 1-1/4 1-1/4 TF5655x /2 1-1/2 TF5655x /8 2 2 TF5655x /8 TuBE atalog Hex cross O.. umber flats 1/4 5719x4 9/ /16 3/8 5707x6 11/ /16 1/2 5719x8 7/ /4 3/4 5707x12 1-1/ / x16 1-1/ /16 1/4 TF5707x4 9/ /16 5/16 TF5707x5 5/ /16 3/8 TF5707x6 11/ /8 1/2 TF5707x8 7/ /16 5/8 TF5707x /8 3/4 TF5707x12 1-1/ /8 7/8 TF5707x14 1-3/ /4 1 TF5707x16 1-1/ /8 1-1/4 TF5707x /2 TF5707x24 2-1/ TF5707x32 2-7/ /8 vailable in Stainless Steel. HOSE SSEBY TEHI T 300 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

60 JI 37 Flare-Twin vailable in Stainless Steel. PPITIO T Bulkhead Branch Tee (Ref. SE o ) I 1 TuBE atalog I 1 cross O.. umber flats 1/4 TF5725x /2 3/8 TF5725x /8 1/2 TF5725x /16 5/8 TF5725x /16 3/4 TF5725x /8 1 TF5725x /8 1/4 5737x /16 3/8 5737x /16 Bulkhead nut not included. ust be ordered separately. See page 277 for bulkhead nut. SPEITY HOSE HIGH OW & EIU Straight Thread O-Ring Branch Tee (Ref. SE o ) Example assembly o x4 Tube Port atalog cross O.. Size umber flats 1/4 1/4 5715x /16 3/8 3/8 5715x /16 1/2 1/2 5715x /4 5/8 5/8 5715x /8 3/4 3/4 5715x / x /16 1/4 1/4 TF5715x /16 5/16 5/16 TF5715x /16 3/8 3/8 TF5715x /8 1/2 1/2 TF5715x /4 5/8 5/8 TF5715x /16 3/4 3/4 TF5715x /8 7/8 7/8 TF5715x /4 1 1 TF5715x /8 1-1/4 1-1/4 TF5715x /4 1-1/2 1-1/2 TF5715x ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES Replacement O-rings listed on page 302. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

61 PPITIO T JI 37 Flare-Twin vailable in Stainless Steel. OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES HOSE SSEBY ross (Ref. SE o ) Straight Thread O-Ring I.. aterial: Buna- 90 urometer Temperature Range: -40 F to +250 F (-40 to +121 ) Standard O-ring complies with SE specification SE J515 Type H. W TuBE atalog cross O.. umber flats 1/4 TF5955x /2 5/16 TF5955x /16 3/8 TF5955x /8 1/2 TF5955x /16 5/8 TF5955x /16 3/4 TF5955x /8 7/8 TF5955x /4 1 TF5955x /8 1-1/4 TF5955x /4 1-1/2 TF5955x /4 5967x /16 3/8 5967x /16 1/2 5967x /4 TuBE atalog W I.. O.. umber 1/ x /8 7629x / x /4 7629x / x /8 7629x / x /2 7629x /8 7629x /4 7629x /8 7629x x /4 7629x /2 7629x x TEHI T 302 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

62 Steel I Fittings PPITIO T ETRI TUBE Od ight 12x1.5 14x1.5 16x1.5 18x1.5-22x1.5-26x1.5-30x2.0-36x Heavy 14x1.5 16x1.5 18x1.5 20x1.5 22x1.5-24x1.5-30x2.0-36x2.0-42x2.0 52x2.0 Typical pplication Used in applications to adapt connections made to I (eutsche Industrie orme) specifications to male 37 JI Flare. Sealing ethod Three-Piece Flareless Bite Type or 60 or 24 Tube Seat, or 37 Flare. Vibration Rating Three-Piece Flareless Bite Type or 60 or 24 Tube Seat. Fair Resistance. aterial arbon Steel - SE 1214 Plating Bodies and Sleeves - Zinc Yellow ichromate Finish uts - Phosphate oating. dvantages Provides an adapter to convert a metric hose assembly to JI 37 allowing the use of standard hose and end fittings.an also be used in the repair of metric tubing. Presetting Instructions 1. Preset with preset tool. ll sleeves should be preset in tool prior to installation. 2. ut the tubing squarely and lightly deburr the end of the tubing inside and out. 3. ubricate the sleeve, nut and threads with a good grade of lubricant compatible with the system fluid. 4. Slide the nut and sleeve on the tubing. The thicker end of the sleeve should be towards the nut. 5. Insert the tube into the preset tool making sure it is bottomed on the tube stop. Tighten the nut by hand as much as possible. 6. On the tube sizes up to and including 18mm O.., tighten the nut 1-1/2 turns past hand tight. For larger tube O.. s, tighten the nut 1-1/4 turns past hand tight. 7. To inspect preset, mark the nut location and remove nut. 8. To reinstall, tighten the nut 1/6 turn (one hex flat) past the previous nut location. Ordering Information Order individually by catalog number. Preset tools found on page 431. SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

63 PPITIO T Steel I Fittings OTE: ultiply millimeters (mm) by to obtain inches. OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS etric Flareless Sleeve etric Flareless ut ight Series (I 3901/3902) Tube atalog l O.. (mm) umber (mm) x x x x x x x x x x x x x x Tube atalog t hex l O.. (mm) umber thd. c (mm) (mm) x6 12x a x8 14x x10 16x x12 18x x15 22x x18 26x x22 30x x28 36x PTERS & HOSE ES HOSE SSEBY TEHI T etric Flareless ut Heavy Series (I /3902S) Tube atalog t hex l O.. (mm) umber thd. c (mm) (mm) 6 H7105x6 14x H7105x8 16x H7105x10 18x H7105x12 20x H7105x14 22x H7105x16 24x H7105x20 30x H7105x25 36x H7105x30 42x H7105x38 52x ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

64 Steel I Fittings OTE: ultiply millimeters (mm) by to obtain inches. PPITIO T ale JI 37 to 24 etric Tube Seat (ight) (I 3901/3902) ale JI 37 to 24 etric Tube Seat (Heavy) (I 3901/3902) tube Tube atalog metric hex O.. O.. (mm) umber thd. c d d1 l 1/ x4x6 12x1.5 5/ / x6x8 14x1.5 3/ / x8x10 16x1.5 7/ / x8x12 18x1.5 15/ / x10x15 22x / / x12x18 26x / tube Tube atalog metric hex O.. O.. (mm) umber thd. c d d1 l 3/ x6x6 14x1.5 3/ / x8x10 18x1.5 15/ / x10x14 22x / / x12x16 24x / SPEITY HOSE HIGH OW & EIU ale JI 37 to 60 etric Tube Seat (I 7631) tube Tube atalog metric hex O.. O.. (mm) umber thd. c d d1 l 1/ x4x6 12x1.5 1/ / x6x8 14x1.5 5/ / x6x10 16x1.5 7/ / x8x12 18x1.5 15/ / x10x15 22x / / x12x18 26x / ESSORRIES & S BY ISTRUTIOS ale JI 37 to ale etric Standpipe (I 7631) tube Tube atalog hex O.. O.. (mm) umber l d 1/ x4x6 9/ / x4x8 9/ / x6x10 3/ / x8x12 7/ / x8x14 7/ / x10x / x10x / x12x16 1-1/ / x12x18 1-1/ / x12x20 1-1/ x16x22 1-1/ x16x25 1-1/ ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

65 PPITIO T Straight Thread O-Ring OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS PTERS & HOSE ES Straight Thread O-Ring Hex Socket Plug (Ref. SE o B) Replacement O-rings page 302. OTE: Parts furnished with zinc plate. Straight Thread O-Ring Hex Head Plug (Ref. SE o ) Replacement O-rings page 302. OTE: Parts furnished with zinc plate. ale Straight Thread/Female Straight Thread O-Ring Boss Replacement O-rings page 302. OTE: Parts furnished with zinc plate. 1 1 port atalog hex size umber l 1/8 7238x2 1/8.40 3/ x3 1/8.40 1/4 7238x4 3/ / x5 3/ /8 7238x6 1/4.50 1/2 7238x8 5/ /8 7238x10 3/8.65 3/4 7238x12 9/ /8 7238x14 9/ x16 5/ /4 7238x20 3/4.78 port atalog hex d1 size umber l OPT. 1/8 7237x2 7/ / x3 1/ /4 7237x4 9/ / x5 5/ /8 7237x6 11/ /2 7237x8 7/ /8 7237x /4 7237x12 1-1/ /8 7237x14 1-3/ x16 1-1/ /4 7237x20 1-7/ /2 7237x24 2-1/ x32 2-3/ male female atalog hex port size port size umber c d l 1/2 3/8 7033x8x6 7/ /8 1/2 7033x10x /4 1/2 7033x12x8 1-1/ /8 3/4 7033x14x12 1-3/ /2 7033x16x8 1-1/ /4 7033x16x12 1-1/ /4 3/4 7033x20x12 1-7/ /2 1-1/4 7033x24x20 2-1/ /2 7033x32x24 2-3/ HOSE SSEBY TEHI T Straight Thread O-Ring Union Replacement O-rings page Hex Hex port atalog hex size umber d l 1/4 5314x4x4 9/ /8 5314x6x6 11/ /2 5314x8x8 7/ /8 5314x10x /4 5314x12x12 1-1/ x16x16 1-1/ /4 5314x20x20 1-7/ /2 5314x24x24 2-1/ x32x32 2-3/ ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

66 Straight Thread O-Ring ale Straight Thread O-Ring to ale Pipe dapter Replacement O-rings page 302. Straight Thread O-Ring to Female Pipe dapter Replacement o-rings page 302. B-Thread B-Thread port male atalog straight hex size pipe thd. umber thd B d l 1/4 1/8 3249x4x2 7/ / /8 1/4 3249x6x4 9/ / /2 3/8 3249x8x6 3/4 16 7/ /2 1/2 3249x8x8 3/4 16 7/ /8 1/2 3249x10x8 7/ /4 3/4 3249x12x12 1-1/ / x16x16 1-5/ / /4 1-1/4 3249x20x20 1-5/ / /2 1-1/2 3249x24x24 1-7/ / x32x32 2-1/ / port female atalog straight hex size pipe thd. umber thd B d l 1/4 1/8 3269x4x2 7/ / /4 1/4 3269x4x4 7/ / /16 1/8 3269x5x2 1/2 20 5/ /8 1/4 3269x6x4 9/ / /8 3/8 3269x6x6 9/ / /8 1/2 3269x6x8 9/ / /2 1/4 3269x8x4 3/4 16 7/ /2 3/8 3269x8x6 3/4 16 7/ /2 1/2 3269x8x8 3/ / /8 1/4 3269x10x4 7/ /8 3/8 3269x10x6 7/ /8 1/2 3269x10x8 7/ / /8 3/4 3269x10x12 7/ / /4 1/2 3269x12x8 1-1/ / /4 3/4 3269x12x12 1-1/ / /8 3/4 3269x14x12 1-3/ / /2 3269x16x8 1-5/ / /4 3269x16x12 1-5/ / x16x16 1-5/ / / x20x16 1-5/ / /4 1-1/4 3269x20x20 1-5/ /2 1-1/2 3269x24x24 1-7/ / x32x32 2-1/ / PPITIO T SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS Straight Thread O-Ring onnector to For-Seal (Ref. SE o ) Replacement straight o-rings page 302. HEX male port atalog hex tube O.d. size umber c d d1 l 1/4 1/4 4315x4 5/ /4 3/8 4315x4x6 11/ /8 1/4 4315x6x4 3/ /8 3/8 4315x6 3/ /8 1/2 4315x6x8 7/ /8 5/8 4315x6x10 1-1/ /2 3/8 4315x8x6 7/ /2 1/2 4315x8 7/ /2 5/8 4315x8x /2 3/4 4315x8x12 1-1/ /8 5/8 4315x10 1-1/ /4 3/4 4315x12 1-1/ / x12x16 1-1/ /4 4315x16x12 1-1/ x16 1-1/ /4 4315x16x20 1-7/ / x20x16 1-3/ /4 1-1/4 4315x20 1-7/ /2 1-1/2 4315x24 2-1/ ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

67 PPITIO T I onnectors OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS Sleeve 3 Piece etric (Ref. SE o ) dapts standard JI Flare-Twin fittings for use with metric tubing 33 Typical pplication Used in applications to adapt connections and tubing to male and female swivel 37 JI flare. Sealing ethod Tapered pipe thread, or o-ring, or 37 flare. Vibration Rating Fair resistance. aterial arbon Steel SE Plating Zinc yellow dichromate finish. dvantages Provides an adapter to convert etric ports to 37 JI allowing the use of standard hose and end fittings. lso metric tubing that can be flared can be adapted to a standard 37 JI connection by the use of sleeves. Ordering Information Order individually by catalog number. tube o.d. tube O.. atalog I. size etric umber d l 1/ x4x / x5x / x6x / x8x / x10x / x10x / x10x / x12x / x14x / x14x x16x / x20x / x20x / x24x PTERS & HOSE ES HOSE SSEBY ale JI 37 to ale etric Straight Thread onnector (Port Per ISO 9974) Replacement O-rings page 309. tube male thd. atalog hex o.d. metric umber l c 1/4 10x x4x /8 1/4 12x x4x /8 1/4 14x x4x /4 3/8 14x x6x /4 3/8 16x x6x /8 1/2 18x x8x /16 1/2 22x x8x /16 5/8 20x x10x /4 22x x12x /8 3/4 27x x12x /4 1 33x x16x /8 1-1/4 42x x20x TEHI T 308 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

68 etric onnectors Female JI 37 Swivel to ale etric Taper Pipe Thread (Pipe Thread Per I 3852) etric 24 (I 3901/3902 I. Rh)/ 37 Flare W W W 90 Elbow - ale JI 37 to ale etric Straight Thread (For ISO 9974 Port) Replacement retaining rings and O-rings see below. etric Retaining Ring W W 1 T1 I.. O I.. I.. O.. I.. O.. I.. O.. I.. O.. 1 T2 tube taper pipe atalog hex hex o.d. thd. metric umber c c1 d l 1/4 10 x x4x6 9/16 9/ /16 12 x x5x8 11/16 5/ /8 14 x x6x10 11/16 11/ /2 16 x x8x12 7/8 7/ /8 20 x x10x /4 24 x x12x20 1-1/8 1-1/ x x16x25 1-3/8 1-1/ /4 36 x x20x32 1-7/ Part o (ash Size) ash Tube Thread Thread Size O.. T1 T2 mm inches mm inches 4-4T 6, x / , tube male thd. atalog o.d. metric umber m n 1/4 10x x4x /4 12x x4x /8 14x x6x /8 16x x6x /2 18x x8x /2 22x x8x /8 18x x10x /8 20x x10x /8 22x x10x /4 22x x12x /4 27x x12x x x16x tube o.d. atalog ring i.d. ring o.d. w (mm) umber (mm) (mm) (mm) x x x x x x x x x x PPITIO T SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES etric O-Ring (For ISO 9974 Port) I.. I.. I.. I.. I.. I.. W aterial: Buna 90 urometer Temperature Range: -40 F to +250 F (-40 to +121 ) W W W W tube atalog w i.d. o.d. umber (mm) (mm) x x x x x x x x x x ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

69 PPITIO T BSP onnectors OW & EIU Typical pplication: Used in applications to adapt connections made to BSP (British Standard Pipe) specifications to male or female swivel SE 37 flare. Sealing ethod: Tapered (BSPT) or Parallel Pipe Thread (BSPP), O-Ring or JI 37 flare. Vibration Rating: Fair resistance. aterial: arbon steel Plating: Zinc dvantages: Provides an adapter to convert BSP ports to 37 allowing the use of standard connectors. Pipe Size 1/8 1/4 3/8 1/2 5/8 3/ /4 Thread Size 1/8 28 1/4 19 3/8 19 1/2 14 5/8 14 3/ /4 11 HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS Hex Head Plug BSPT PIPE TOG HEX d OPT. oupling T SIZE UBER () T I. 1/8 3159x /4 3159x /8 3159x /2 3159x /4 3159x x BSPT PIPE TOG HEX d OPT. SIZE UBER () I. 1/8 3309x /4 3309x /8 3309x /2 3309x /4 3309x x PTERS & HOSE ES HOSE SSEBY TEHI T Hex ipple BSPT BSPT Pipe Pipe hex Size Size atalog 1 umber (mm) T T1 1 1/8 1/8 3069x2x /8 3069x4x /4 1/4 3069x4x /8 1/4 3069x6x /8 3/8 3069x6x /2 3/8 3069x8x /2 1/2 3069x8x /4 1/2 3069x12x /4 3/4 3069x12x /4 3069x16x x16x / x20x /4 1-1/4 3069x20x /2 1-1/4 3069x24x /2 1-1/2 3069x24x /2 3069x32x x32x ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

70 BSP onnectors PPITIO T ale onnector 1 B BSPT BSPT Tube Pipe atalog Thread hex O.. Size umber B c 1 1/4 1/8 5205x4x2 1/ / /4 1/4 5205x4x4 1/ / /4 3/8 5205x4x6 1/ / /16 1/4 5205x5x4 1/ / /16 3/8 5205x5x6 3/ / /8 1/4 5205x6x4 1/ / /8 3/8 5205x6x6 3/ / /8 1/2 5205x6x8 1/ / /8 3/4 5205x6x12 3/ / /2 3/8 5205x8x6 3/ / /2 1/2 5205x8x8 1/ / /2 3/4 5205x8x12 3/ / /8 1/2 5205x10x8 1/ / /8 3/4 5205x10x12 3/ / / x10x / /4 1/2 5205x12x8 1/ / / x12x / /8 3/4 5205x14x12 3/ / / x14x / /4 3/4 5205x12x12 3/ / /4 5205x16x12 3/ / x16x / /4 1-1/4 5205x20x20 1-1/ / /2 1-1/2 5205x24x24 1-1/ / x32x / SPEITY HOSE HIGH OW & EIU ale onnector 60 T1 T2 37 ale British Standard Parallel Pipe to ale 37 SE Part o (ash Size) ash Tube Thread Thread Size O.. T1 (bspp) T2 mm inches mm inches 2-4S 6, / / , S 6, / / , S 9, / / , S 9, / / , S 16, / / , S 19, / / , S 25, / , B BSPP BSPP Tube Pipe atalog Thread hex O.. Size umber B l c 1/4 1/8 B5315x4x2 1/ /8 1/4 1/4 B5315x4x4 1/ /4 5/16 1/4 B5315x5x4 1/ /4 3/8 1/4 B5315x6x4 1/ /4 3/8 3/8 B5315x6x6 3/ /8 1/2 3/8 B5315x8x6 3/ /8 1/2 1/2 B5315x8x8 1/ /8 5/8 3/4 B5315x10x12 3/ /8 3/4 3/4 B5315x12x12 3/ /8 1 1 B5315x16x /4 1-1/4 1-1/4 B5315x20x20 1-1/ Replacement retaining rings and O-Rings page 313. ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES TEHI T HOSE SSEBY

71 PPITIO T BSP onnectors OW & EIU HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS Female 37 SE Swivel to ale British Standard Tapered Pipe Thread Female 37 SE Swivel to ale British Standard Parallel Pipe Thread 1 60 B 1 B 1 1 atalog Tube BSPT umber BSPT Hex Hex O.. Pipe Size Pipe Size 1 1 1/4 1/4 9800x4x4 1/4 9/16 9/ * /16 1/4 9800x5x4 1/4 11/16 5/ * /8 1/4 9800x6x4 1/4 11/16 11/ /2 1/4 9800x8x4 1/4 7/8 7/ /2 3/8 9800x8x6 3/8 7/8 7/ * /2 1/2 9800x8x8 1/2 7/8 7/ * /8 1/2 9800x10x8 1/ * /4 1/2 9800x12x8 1/2 1-1/8 1-1/ /4 3/4 9800x12x12 3/4 1-1/8 1-1/ * /4 9800x16x12 3/4 1-3/8 1-1/ x16x /8 1-1/ * /4 1-1/4 9800x20x / * 2.73 *Optional counterbore. atalog Tube BSPP umber BSPT Hex Hex O.. Pipe Size Pipe Size 1 1 1/4 1/4 9600x4x4 1/4 9/16 9/ * /16 1/4 9600x5x4 1/4 5/8 11/ /8 1/4 9600x6x4 1/4 11/16 11/ /8 3/8 9600x6x6 3/8 11/16 11/ * /2 3/8 9600x8x6 3/8 7/8 7/ /2 1/2 9600x8x8 1/2 7/8 7/ * /8 1/2 9600x10x8 1/ /4 3/4 9600x12x12 3/4 1-1/4 1-1/ * x16x /2 1-3/ * /4 1-1/4 9600x20x20 1-1/ / * 2.64 *Optional counterbore. PTERS & HOSE ES HOSE SSEBY ale British Standard Tapered Pipe to ale SE 37 SE 90 Elbow B BSPT BSPT cross Tube Pipe atalog Thread flats O.. Size umber B 1/4 1/4 5405x4x4 1/ /16 5/16 1/4 5405x5x4 1/ /2 3/8 1/4 5405x6x4 1/ /16 3/8 3/8 5405x6x6 3/ /4 1/2 3/8 5405x8x6 3/ /4 1/2 1/2 5405x8x8 1/ /8 5/8 3/4 5405x10x12 3/ /16 3/4 3/4 5405x12x12 3/ / x16x /16 1-1/4 1-1/4 5405x20x20 1-1/ /8 TEHI T 312 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006

72 BSP onnectors PPITIO T ale British Standard Parallel Pipe to ale 37 SE 90 Elbow British Retaining Ring British O-Ring aterial: Buna 90 urometer Temperature Range: -40 F to +250 F (-40 to +121 ) W W I.. O.. I.. O.. BSPP Tube Pipe atalog BSPP cross O.. Size umber Thread Flats 1/4 1/4 B5515x4x4 1/ /16 5/16 1/4 B5515x5x4 1/ /16 3/8 1/4 B5515x6x4 1/ /16 3/8 3/8 B5515x6x6 3/ /4 1/2 3/8 B5515x8x6 3/ /4 1/2 1/2 B5515x8x8 1/ /8 5/8 3/4 B5515x10x12 3/ /16 3/4 3/4 B5515x12x12 3/ / B5515x16x /16 1-1/4 1-1/4 B5515x20x /8 Replacement retaining rings and O-Rings see below. TuBE atalog Ring W O.. umber Ring I.. O.. 1/8 B7630x /4 B7630x /8 B7630x /2 B7630x /8 B7630x /4 B7630x B7630x /4 B7630x /2 B7630x TuBE atalog O.. umber W I.. 1/8 B7629x /4 B7629x /8 B7629x /2 B7629x /8 B7629x /4 B7629x B7629x /4 B7629x SPEITY HOSE HIGH OW & EIU ESSORRIES & S BY ISTRUTIOS PTERS & TUBE HOSE ES ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September TEHI T HOSE SSEBY

73 PPITIO T Special dapters OW & EIU 8111 onnector (Steel) mle Tube Pipe atalog Size Thread umber 1 (1-5/16 14) 3/ (1-5/16 14) PPITIO: PTT Thread 30 tube to male pipe adapter for iesel Engines Restriction Pipe dapter (Brass) With.0625 Orifice ale Pipe Fem. Pipe atalog Size Thread umber 1/8 1/ HIGH SPEITY HOSE ESSORRIES & S BY ISTRUTIOS JI 37 Flare to O-Ring Port (Steel) Includes O-Ring B JI 37 Flare to etric O-Ring Port dapter (Steel) Includes O-Ring B Tube Thread Thread atalog Size B umber 1/4 7/ / x4 3/8 9/ / x6 1/2 3/4 16 3/ x8 5/8 7/8 14 7/ x10 3/4 1-1/ / x12 Includes O-Ring. Tube Thread Thread atalog Size B umber 3/8 14x1.5 9/ x6x14 3/8 16x1.5 9/ x6x16 3/8 18x1.5 9/ x6x18 Includes O-Ring. PTERS & HOSE ES pplication: G power steering with Saginaw steering and rack and pinion steering systems. HOSE SSEBY ale Pipe to 30 Flare 30º 30 Part o (ash Size) ash Tube Thread Thread Size O.. P (nptf) T mm inches mm inches 16-16S 25, / / , P T TEHI T 314 ETO Weatherhead Hose ssembly aster atalog W-HYOV-002-E1 September 2006