Honda Ridgeline Installation Instructions

Size: px
Start display at page:

Download "Honda Ridgeline Installation Instructions"

Transcription

1 Honda Ridgeline Installation Instructions READ THIS... If you read these instructions from beginning to end before starting you will probably not need to look at them again during the installation, but feel free to lf you must. Tools Needed: T-40 TORX Driver Contents: 2-pieces of weather bulb seal 3- inches long 10 MM socket 2- Z shaped steel brackets #3 Phillips Screwdriver 2- Flat steel brackets Scissors 2- V shaped brackets 1/8-inch drill bit 2-pivot point brackets Drill 2 - L brackets 2- Bedrails, Weather seal attached, (one will be marked as drivers side) 2- rails 20 with weather seal attached 26- #12 screws ¾ long 4- M6 steel screws 1-3/16 (30mm) long 2- M6 screws 1-3/8 (35mm) long 4- large flat washers 2- coupler nuts ¾ long 1-cab cross-bar with weather bulb seal 50 long 2-Bow-shaped cross-bars 2-hinged frame assemblies 2-43-inch long Black Webbing Straps 2- black plastic parts with 4 # 12 screws and 2 small #20 self drilling screws 2-12-inch ¾-inch diameter aluminum tube 1-44-inch 7/8-inch diameter aluminum tube Page 1

2 Important note: All mounting brackets have oval slots which allow for minor adjustments after initial installation. Step 1. Attach the V-shaped brackets to front ends of the main bedrails with the #12 screws provided. Holes are pre-drilled. They should be pointing forward, upward and inward. (See photos) Do not attach the small rails yet! Step 2. Using a TORX T-40 driver remove the 4 factory bolts that hold on the truck box side panels (2 on each side). (Loosely) Install the Z- brackets and the flat brackets with the M6 screws and large flat washers. (See photo). Step 3. Remove the white strip from the bottom of the main bedrails. Note: The weather stripping does not have adhesive and will not stick to your truck. Place the Bedrails into position and using the #12 screws and loosely attach the bedrails to the steel brackets. Don t forget to include and center the pivot point bracket with the flat steel bracket. (See Photo) Step 4. Hold the smaller rails in position lining up the holes as if you were going to join them to the main bedrails. Measure the gap between the small rail and the plastic molding edge below the front of the main bedrail. The gap is approximately 2 long. These gaps need to be dammed up with the two small pieces of bulb seal. Cut to shorten if necessary, remove the backing and install in place. (See photo) Page 2

3 Step 5. While pressing down hard on a bedrail tighten the bedrail to the brackets and the steel brackets to the vehicle. This will compress the weather seal. Do the other side. Step 6. Using a small flat screwdriver or similar remove the 2 small plastic tabs from the rear left and right cab area. Now remove the 2 nuts with a 10 mm wrench. (Retain these parts for future use) Now install the Coupler nuts securely onto the threaded posts. (See photo) Using the M6 screws, install one end of the 50 cross-bar (loosely for now, just a couple of threads in). Note: Weather bulb is compressed against cab, and the snap studs face forward. Now while pressing down firmly on the other end of the crossbar, attach the other side. (See photo) Step 7. Position the flat weather-sealed upper portion of the small rails under the last inch of the cab cross-bar (snaps facing out). Force the lower end of the small rail down towards its attachment point on the main bedrail. Note: It may take a little trial and error to create a tight fit to the vehicle but it is quite easy to bend the flat bar around your knee and then reposition. Using the #12 screws, attach the small rail to the main bedrail. Tighten down the cab cross bar and all other screws and bolts securely. (See photo) Step 8. Install the black plastic parts to the rear of the bedrails with the #12 screws provided. The part marked with an A should be on the passenger side. The part marked with a B should be on the driver s side (See photo) Page 3

4 Step 9. The round aluminum bows and their pivoting counterparts are color coded to match up with each other. Caution: Try not to pinch your fingers when fitting these parts together. This is a good time to place the two 1 adjustable straps on the rear bow (See photo). The bar with the snap studs on it will be to the rear of the vehicle when installed. Place the Bow frame assembly up onto the rear of the vehicle and remove the circular clips from the pivot pins on the bedrails. Position the frame onto the pivot pins and replace the circular clips. Step 10. Unfold the Softopper canopy and place it on the tailgate. Attach the snaps to the rear bow section. Place the 1-inch webbing support straps between the 2 nd and 3 rd snap on each end of the rear bow. Now pull the rest of the canopy forward and attach the snaps to the front/cab cross-bar - just the 11 horizontal snaps for now. Attach the support straps around the remaining forward bow. Adjust the webbing straps to a loose position for now and tighten later. Now you are ready to attach the remaining snaps to the bedrails working your way from the front towards the rear, snap after snap. The straps on the rear of the frame can be attached to the bedrails and pulled tight to help. Pull down on the rear bow if you need to. Note: New tops can be quite taut. Loosen the straps a little after the fabric is snapped in place so the fabric is under tension. This will help it to stretch and set. Now do the other side. Step 11. Insert a 12-inch tube into each end of the longer 44-inch tube, with the plastic end caps out. Press the bar assembly into the black snap-fit plastic parts on the bedrail, adjusting the total length as necessary for a tight side-to-side fit. The idea is to have the larger tube centered and have as little side-to-side movement as possible once secured in the plastic parts and have equal lengths of the smaller tubes protruding from each end. Mark the location of where the smaller tubes enter the larger tube. The longer tube has pre-drilled holes in each end. These holes will be used to guide a 1/8 inch drill bit into the smaller tube. Hold the smaller tube securely in the larger tube at the correct location and drill through. Install the #20 screw and repeat on the other end. Insert the finished tube assembly into the window panel sleeve, press into snap-fit parts on both sides and check fit. VELCRO - Take the 3 pieces of Velcro Tape. With the rear window panel installed pull down the zippers and adjust so that the back flap sits nicely along the rear of the vehicle. Tug gently on the back flap and find the place where it seems to sit easily. There is Velcro (loop) sewn along the bottom inside edge of the back flap. This is where the Velcro tape must line up once installed on the tailgate. The underside of the plastic protector works well for the Ridgeline. Note: Be sure to clean the area (remove any wax or dirt) where the Velcro will be installed. Install one dead-center, and the other two on opposite ends of the tailgate. Note: Velcro tape will reach maximum holding strength after 24 hours. NOTE: To retract the Softopper, unsnap the side panels and flip them up onto the roof, then retract to the front. When driving with the top in the forward retracted position, you must attach the webbing straps from the rear Softopper bar to the factory anchors at the upper front of the bed. This will ensure that your topper stays in place, and wind gusts will not raise the canopy. Please call or with any questions Page 4

5 Warranty We warrant our Softopper products to be free from defects in material and workmanship for a period of one year, with the exception of vinyl windows and zippers, provided there has been normal use and proper maintenance. Vinyl Windows are warranted for a period of 6 months from the date of purchase. Zippers are guaranteed to be in perfect working condition when leaving the factory. Due to atmospheric conditions, dirt, sand, road grime, dust, and abrasive cleaners, etc., zippers are warranted for a period of 6 months from the date of purchase. Returns must be pre-approved and have Softoppers issued RGA number attached. Any defective items must be returned with proof of purchase to Softopper 4750 Nautilus Ct S Unit B Boulder CO 80301, freight pre-paid. Items returned must be carefully packed, in clean condition, with plastic windows protected from scratching and creasing. This warranty does not cover damage resulting from abuse, misuse, alteration, accident or damage in transit. Softoppers obligations under this warranty are limited to the aforementioned repair or replacement of warranty defects for which return authorization has been received during the warranty period, and Softopper SHALL NOT BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM BREACH OF THIS OR ANY IMPLIED WARRANTY. This warranty applies to the original purchaser only. All remedies under this warranty are limited to repair or replacement of any item or items found to be defective by the factory within the time period specified. For further information or request for repair work, please contact: Softopper LLC, customer service (800) or (303) Page 5

6 Softopper Care and Maintenance Your top is made of the finest materials available. To keep it looking new and for product longevity and durability, it will need periodic cleaning and maintenance. Washing: The fabric should be washed from time to time using a mild soap and warm water. Be sure to rinse all soap off the top when washing is complete. Vinyl Windows: Windows should be kept clean to avoid scratching. Wash with a water-soaked sponge or cloth and a mild dishwashing detergent. Do not use a coarse brush on the windows and never wipe the windows when they are dry. Be careful when clearing snow and frost from the vinyl windows since they are easily scratched. NOTE: Do not use any cleaning agents containing alcohol or silicone. Cold weather: As with all automotive and marine clear vinyls, extreme care must be taken when rolling up or folding in cold temperatures. This point cannot be stressed enough! Clear vinyl becomes stiff in cold temperatures and may crack. Retracting the Softopper in cold temperatures is not recommended. When opening the rear of the Softopper in cold weather, be sure to raise the zippers as high as possible so that any folding will occur to the topper fabric and not to the clear vinyl window. Zippers: Keeping the zippers clean and lubricated with a silicone lubricant will help prevent damage and keep the zippers in smooth working condition. Leakage: As with any sewn automotive top there is always a slight risk of leakage. Right out of the box the Softopper will not be waterproof. Water seeping through at the seams may be stopped by applying Seam Sure (supplied), on the inside of the affected seams. Shake Seam Sure well and apply liberally to the inside seams concentrating on areas where needle and thread penetrated the fabric. Snaps: Keep snaps clean and lubricated with a silicone lubricant to help prevent snaps from sticking to the studs. If a snap does become stuck to a stud, use a screwdriver and gently pry apart to prevent damage to the snap or top fabric. If any snaps need to be replaced due to sticking or damage please call Softopper and we can send out a small do-it-yourself repair kit. For further information please contact: Softopper LLC, customer service (800) or (303) Page 6

4Runner Soft Top Installation Instructions

4Runner Soft Top Installation Instructions 4Runner Soft Top Installation Instructions Very important!! We believe that if you read these instructions from start to finish and look at all the pictures you will probably be able to do the entire installation

More information

International Scout 80/800

International Scout 80/800 International Scout 80/800 Tools needed: sockets wrenches powered drill #2 phillips bit for drill #3 phillips bit for drill or screwdriver tape measure Contents: 2- bedrails, (2 pieces each) 4- bedrail

More information

Ridgeline (A) Installation Instructions

Ridgeline (A) Installation Instructions Ridgeline (A) Installation Instructions Please read instructions thoroughly before starting installation **Remove all contents of the Softopper carefully to protect from scratches.** Windows scratch easily!

More information

Installation Instructions

Installation Instructions Installation Instructions 3rd Generation Chevy Blazer & GMC Jimmy 3 Please read instructions thoroughly before starting installation **Remove all contents of the Softopper carefully to protect from scratches.**

More information

Softopper Installation Instructions (CB)

Softopper Installation Instructions (CB) Softopper Installation Instructions (CB) Please read instructions thoroughly before starting installation **Remove all contents of the Softopper carefully to protect from scratches.** Windows scratch easily!

More information

Softopper Installation Instructions

Softopper Installation Instructions Softopper Installation Instructions (O.S.) Please read instructions thoroughly before starting installation **Remove all contents of the Softopper carefully to protect from scratches.** Windows scratch

More information

Installation Instructions Supertop NX

Installation Instructions Supertop NX Installation Instructions Supertop NX Vehicle Application: Jeep Wrangler Unlimited 2004 2006 Part Number: 54721 www.bestop.com - We re here to help! Visit our web site and click on Ask a Question. Click

More information

TJ Tinted Window Kit. Installation Instructions INSTALLATION TIME SKILL LEVEL TOOLS. Vehicle Application

TJ Tinted Window Kit. Installation Instructions INSTALLATION TIME SKILL LEVEL TOOLS. Vehicle Application Installation Instructions TJ Tinted Window Kit Vehicle Application Jeep TJ 2003 and newer Part Number: 58128 www.bestop.com - We re here to help! Visit our web site and click on Ask a Question. Click here

More information

Required Tools: Phillips screw driver to remove original soft top. Torx sockets are required to completely remove the original soft top hardware.

Required Tools: Phillips screw driver to remove original soft top. Torx sockets are required to completely remove the original soft top hardware. RAMPAGE P R O D U C T S Installation Instructions Part number 1098XX, Frameless Soft Top for 4 door Jeep Wrangler JK 2007- NOTE: Installation of the top in warm weather is optimal for ease of installation.

More information

Installation Instructions WrapAround Windjammer

Installation Instructions WrapAround Windjammer Installation Instructions WrapAround Vehicle Application Jeep Wrangler 2 Door 2007 2009 Part Number: 80041 * Requires Sound Bar Cap 80040 and Factory Door Surrounds www.bestop.com - We re here to help!

More information

Installation Instructions Safari Bikini Top

Installation Instructions Safari Bikini Top Installation Instructions Safari Bikini Top For: 1992-1995 Wrangler Part Number 52529 Congratulations on your purchasing decision. Bestop designed this Convertible Top to give you years of dependability

More information

READ AND SAVE THESE INSTRUCTIONS! EasyAwn Standard Awning Installation

READ AND SAVE THESE INSTRUCTIONS! EasyAwn Standard Awning Installation EasyAwn Installation, Care and Maintenance Manual EasyAwn Quality, Since 1946 EasyAwn, LLC Toll Free: 877-EasyAwn http://www.easyawn.com READ AND SAVE THESE INSTRUCTIONS! EasyAwn Standard Awning Installation

More information

1946 READ AND SAVE THESE INSTRUCTIONS!

1946 READ AND SAVE THESE INSTRUCTIONS! EasyAwn Installation, Care and Maintenance Manual EasyAwn Quality, Since 1946 EasyAwn, LLC Toll Free: 877-EasyAwn http://www.easyawn.com READ AND SAVE THESE INSTRUCTIONS! EasyAwn Quarter Round Awning Installation

More information

READ AND SAVE THESE INSTRUCTIONS! EasyAwn Spear Awning Installation

READ AND SAVE THESE INSTRUCTIONS! EasyAwn Spear Awning Installation EasyAwn Installation, Care and Maintenance Manual EasyAwn Quality, Since 1946 EasyAwn, LLC Toll Free: 877-EasyAwn http://www.easyawn.com READ AND SAVE THESE INSTRUCTIONS! EasyAwn Spear Awning Installation

More information

Factory Style Bow Kit

Factory Style Bow Kit Installation Instructions Factory Style Bow Kit Vehicle Application: Jeep Wrangler Unlimited 2004 2006 Part Number: 55003 www.bestop.com - We re here to help! Visit our web site and click on Ask a Question.

More information

AND LOAD CANOPY RACK SPECIFICATIONS

AND LOAD CANOPY RACK SPECIFICATIONS 8MAY15 INSTRUCTIONS for the LOCK AND LOAD CANOPY RACK SPECIFICATIONS and SAFE LOADING REQUIREMENTS The Lock and Load ladder carrier for Truck Caps is a rack designed to mount to the top of a pickup truck

More information

READ AND SAVE THESE INSTRUCTIONS! EasyAwn Dome Awning Installation

READ AND SAVE THESE INSTRUCTIONS! EasyAwn Dome Awning Installation EasyAwn Installation, Care and Maintenance Manual EasyAwn Quality, Since 1946 EasyAwn, LLC Toll Free: 877-EasyAwn http://www.easyawn.com READ AND SAVE THESE INSTRUCTIONS! EasyAwn Dome Awning Installation

More information

Standard Awning Installation Instructions

Standard Awning Installation Instructions Standard Awning Installation Instructions Important Note: Please become familiar with this entire document BEFORE beginning your installation. The time you spend doing this is well spent and will make

More information

Header Bikini Installation Instructions

Header Bikini Installation Instructions Header Bikini Installation Instructions For: Jeep Wrangler 1997-2002 Part Number: 52525 with or without Soundbar with or without Door Surround DO NOT INSTALL THIS PRODUCT ON ANY VEHICLE OTHER THAN THOSE

More information

CONVEX Awning Instructions

CONVEX Awning Instructions CONVEX Awning Instructions IMPORTANT NOTE: Please take a few minutes to become familiar with this entire document BEFORE beginning your installation. The time you spend doing this is well spent and will

More information

ASSEMBLY & CARE INSTRUCTIONS

ASSEMBLY & CARE INSTRUCTIONS ASSEMBLY & CARE INSTRUCTIONS 7 x TRAILER TENT SERIES 3 9 Part No. FT3711 - on road FT3923 - off road OPTIONAL SUNROOM Wall and floor kit Part No. FT3723 - on road FT39 - off road OPTIONAL SPARE ROOM Roof,

More information

ASSEMBLY & CARE INSTRUCTIONS. 7 x4 TRAILER TENT SERIES 4 9. OPTIONAL SUNROOM Wall and floor kit. OPTIONAL SPARE ROOM Roof, wall and floor kit

ASSEMBLY & CARE INSTRUCTIONS. 7 x4 TRAILER TENT SERIES 4 9. OPTIONAL SUNROOM Wall and floor kit. OPTIONAL SPARE ROOM Roof, wall and floor kit ASSEMBLY & CARE INSTRUCTIONS 7 x TRAILER TENT SERIES 9 Part No. TM709 OPTIONAL SUNROOM Wall and floor kit Part No. TM723 OPTIONAL SPARE ROOM Roof, wall and floor kit Part No. TM76 Please keep these instructions

More information

Otter Pro XT Cabin Installation and Set-Up Instructions

Otter Pro XT Cabin Installation and Set-Up Instructions Otter Pro XT Cabin Installation and Set-Up Instructions Otter Pro XT Cabin Fits Medium Otter Pro and Otter II Sled Only Parts Identification and Check List MODEL NUMBERS: Complete Pkg Pro XT Thermal Cabin

More information

Otter Pro XT 1200 Cottage Installation and Set-Up Instructions

Otter Pro XT 1200 Cottage Installation and Set-Up Instructions Otter Pro XT 1200 Cottage Installation and Set-Up Instructions Otter Pro XT 1200 Cottage Fits Small Ultra-Wide Otter Pro and Otter II Sled Only Parts Identification and Check List MODEL NUMBERS: Complete

More information

Otter XT 650 Cabin Installation and Set-Up Instructions

Otter XT 650 Cabin Installation and Set-Up Instructions Otter XT 650 Cabin Installation and Set-Up Instructions Otter XT 650 Cabin Fits Medium Otter Wild Sled Only Parts Identification and Check List MODEL NUMBERS: Complete Pkg Otter XT 650 Cabin 200891 2 1

More information

Installation Instructions Safari Bikini Top

Installation Instructions Safari Bikini Top Installation Instructions Safari Bikini Top For: 1992-1995 Wrangler Part Number 52529 WARNING This product is designed primarily to enhance the appearance of the vehicle and to shield the occupants from

More information

LITE Spear Awning Instructions

LITE Spear Awning Instructions LITE Spear Awning Instructions IMPORTANT NOTE: Please take a few minutes to become familiar with this entire document BEFORE beginning your installation. The time you spend doing this is well spent and

More information

Installation Instructions

Installation Instructions Installation Instructions For: Jeep Wrangler TJ Strapless Bikini Part Number 52521 To be used with or without Soundbar To be used with or without Door Side Rails Congratulations on your purchasing decision.

More information

Installation Instructions Header Bikini, Safari Version For Use With or Without Door Surrounds

Installation Instructions Header Bikini, Safari Version For Use With or Without Door Surrounds Installation Instructions Bikini, Safari Version For Use With or Without Door Surrounds Vehicle Application Jeep Wrangler JK Unlimited (4 Door) 2010 to Current Part Number: 52584 Must be used with a Windshield

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory FABRIC ROOF/ REAR PANEL (5P) P/N 0SR85-HL4-222A (Black) 0SR85-HL4-221C (Camo) Application SXS1000M5P/M5D Honda Dealer: Please give a copy of these instructions to your

More information

PARTS INCLUDED IN YOUR KIT. You may want to lay them out in this manner for accessibility. Foam has NO adhesive to touch truck finish.

PARTS INCLUDED IN YOUR KIT. You may want to lay them out in this manner for accessibility. Foam has NO adhesive to touch truck finish. -'07 Ford Sport Trac Tarp Assembly with Cab Rail, Tail Rail and Support Bows attached. Left and Right Side Rail Assemblies Sport Trac Brackets (x4) Clamp Bolts Allen Wrench PARTS INCLUDED IN YOUR KIT.

More information

Installation Instructions Header Bikini,Safari Version

Installation Instructions Header Bikini,Safari Version Installation Instructions Bikini,Safari Version Vehicle Application Jeep Wrangler JK (2 Door) 2007 2009 Part Number: 52585 www.bestop.com - We re here to help! Visit our web site and click on Ask a Question.

More information

Installation Instructions Header Bikini, Safari Version

Installation Instructions Header Bikini, Safari Version Installation Instructions Bikini, Safari Version Vehicle Application Jeep Wrangler JK Unlimited (4 Door) 2010 to Current Part Number: 52584 www.bestop.com - We re here to help! Visit our web site and click

More information

SlimShady CONTENTS. SlimShady (1X) Tools Required: nut (4X) stake (2X) bolt (4X) wrench (1X) washer (4X) clamps (2X) stake sack (1X) key (2X)

SlimShady CONTENTS. SlimShady (1X) Tools Required: nut (4X) stake (2X) bolt (4X) wrench (1X) washer (4X) clamps (2X) stake sack (1X) key (2X) SlimShady Tools Required: CONTENTS nut (4X) stake (2X) stake sack (1X) bolt (4X) wrench (1X) washer (4X) key (2X) SlimShady (1X) clamps (2X) 1 ASSEMBLE & INSTALL Be sure the awning is oriented correctly

More information

READ AND SAVE THESE INSTRUCTIONS! EasyAwn Dome Awning Installation

READ AND SAVE THESE INSTRUCTIONS! EasyAwn Dome Awning Installation EasyAwn Installation, Care and Maintenance Manual EasyAwn Quality, Since 1946 EasyAwn, LLC 3575 Trotters Drive, Bldg A Alpharetta, GA 30004 Toll Free: 877-EasyAwn http://www.easyawn.com READ AND SAVE THESE

More information

PARTS INCLUDED IN YOUR KIT. You may want to lay them out in this manner for accessibility. Foam has NO adhesive to touch truck finish.

PARTS INCLUDED IN YOUR KIT. You may want to lay them out in this manner for accessibility. Foam has NO adhesive to touch truck finish. INSTALL ATION SHEET Tarp Assembly with Cab Rail, Tail Rail and Support Bows attached. Left and Right Side Rail Assemblies U Clamps (x 6) NOTICE: If your truck has a bedliner that wraps over any top edges,

More information

Installation Instructions Header Bikini, Safari Version

Installation Instructions Header Bikini, Safari Version Installation Instructions Bikini, Safari Version Vehicle Application Jeep Wrangler JK Unlimited (4 Door) 2007 and newer Part Number: 52581 www.bestop.com - We re here to help! Visit our web site and click

More information

Installation and User s Manual 12 x 10 MOTORIZED AWNING

Installation and User s Manual 12 x 10 MOTORIZED AWNING 12 x 10 MOTORIZED AWNING Installation and User s Manual 12 x 10 MOTORIZED AWNING 088-1763-0 Stop Please read and understand this manual before any assembly or use of this product. Before beginning assembly

More information

Otter XT Cabin Installation and Set-Up Instructions

Otter XT Cabin Installation and Set-Up Instructions Otter XT Cabin Installation and Set-Up Instructions Otter XT Cabin Fits Medium Otter Wild Sled Only Parts Identification and Check List MODEL NUMBERS: Complete Pkg Otter XT Cabin 200962 2 1 PARTS LIST

More information

Manual Awning. Assembly Instructions. Product No Toll-free:

Manual Awning. Assembly Instructions. Product No Toll-free: Manual Awning Product No. 088-30- Instructions Toll-free: -877-483-679 IMPORTANT: Please read this manual carefully before beginning assembly of this product. Keep this manual for future reference. 3 Table

More information

Otter Pro X-Over Lodge Installation and Set-Up Instructions

Otter Pro X-Over Lodge Installation and Set-Up Instructions Otter Pro X-Over Lodge Installation and Set-Up Instructions Otter Pro X-Over Lodge Fits Magnum Otter II & Pro Sled Only Parts Identification and Check List MODEL NUMBERS: Complete Pkg Pro X-Over Lodge

More information

LM601 Landmark Permanent Blind

LM601 Landmark Permanent Blind LM601 Landmark Permanent Blind Get parts online at www.huntriversedge.com P/N: 26742 REV1: 01/13/17 2017 RETI All Rights Reserved INTRODUCTION Landmark Permanent Blinds are engineered with you the hunter

More information

INSTALLATION SHEET. PARTS INCLUDED IN YOUR KIT. You may want to lay them out in this manner for accessibility.

INSTALLATION SHEET. PARTS INCLUDED IN YOUR KIT. You may want to lay them out in this manner for accessibility. INSTALLATION SHEET Gas Struts (x2) Lower Hinge Rail Side Rails (L and R) Spring Bows (x2-short Bed) (x3-long Bed) L Bars (L and R) with clamps included L Channel w/seal MISSING PARTS??? Call Extang at

More information

UltraGroove and UltraGroove Metal

UltraGroove and UltraGroove Metal UltraGroove and UltraGroove Metal Retractable Tonneau Covers INSTALLATION INSTRUCTIONS CHEVROLET COLORADO/CANYON TABLE OF CONTENTS (800) 338-3697 www.paceedwards.com Pace Edwards Company 2400 Commercial

More information

Safety instructions and warnings Package contents and parts Tool requirements Product features... 5

Safety instructions and warnings Package contents and parts Tool requirements Product features... 5 Door Awning : PA Series Owner s Manual For safety reasons, please carefully read and understand all written instructions and warnings in this manual prior to assembling or installing this product. Table

More information

QuadraTop Bimini Top and Bimini Top Plus

QuadraTop Bimini Top and Bimini Top Plus QuadraTop Bimini Top and Bimini Top Plus Installation Manual for 07- Current Jeep JK Wrangler Vehicles # 11022.0435, # 11022.1435 and 11022.1335 BIMINI PLUS BIMINI Loss of vehicle control involves risk

More information

Model 205 Fireview Maintenance Kit

Model 205 Fireview Maintenance Kit Model 205 Fireview Maintenance Kit Please read all of the instructions before you begin the procedure. Confirm that you have all the necessary tools and parts required. Allow about one hour to complete

More information

Safety instructions and warnings Package contents and parts Tool requirements Product features... 4

Safety instructions and warnings Package contents and parts Tool requirements Product features... 4 Door Awning : PN Series Owner s Manual For safety reasons, please carefully read and understand all written instructions and warnings in this manual prior to assembling or installing this product. Table

More information

OWNER'S MANUAL CAMPOUT TABLE OF CONTENTS

OWNER'S MANUAL CAMPOUT TABLE OF CONTENTS OWNER'S MANUAL CAMPOUT RV Before operating the awning, carefully review the Owner's Manual. The manual contains important safety information, detailed operating instructions, common maintenance procedures

More information

INSTALLATION SHEET -Explorer Sport Trac

INSTALLATION SHEET -Explorer Sport Trac INSTALLATION SHEET -Explorer Sport Trac Long Neck Side Rail Clamps (x2) Cab Rail (BlackMax includes snaps on this rail) Side Rails Clamp Bolts Short Neck Side Rail Clamps (x2) Allen Wrench (3/16") Sport

More information

Installation Instructions Traditional Awnings in a box Classic Awnings in a Box

Installation Instructions Traditional Awnings in a box Classic Awnings in a Box Installation Instructions Traditional Awnings in a box Classic Awnings in a Box Basic Tools Required (not included) Tape Measure & Pencil Level Phillips Screwdriver Drill with ¼ bit (Cement or Masonry

More information

HARD DOOR UPGRADE KIT

HARD DOOR UPGRADE KIT RV Accessories OWNER'S MANUAL HARD DOOR UPGRADE KIT FOR ADD-A-ROOM & BREEZEWAY SCREEN ROOMS THIS MANUAL SUPPLEMENTS THE ADD-A-ROOM INSTRUCTIONS TABLE OF CONTENTS First Time Assembly... 2 Assembling the

More information

Compass Home 8' x 8' No Tools Gazebo with Awning and Anchor Bags Assembly Instruction for Gazebo (no tools required)

Compass Home 8' x 8' No Tools Gazebo with Awning and Anchor Bags Assembly Instruction for Gazebo (no tools required) Compass Home 8' x 8' No Tools Gazebo with Awning and Anchor Bags Assembly Instruction for Gazebo (no tools required) CAUTION: Read all instructions before assembly. Failure to do so may result in faulty

More information

SOLHARO ASSEMBLY & INSTALLATION INSTRUCT IONS

SOLHARO ASSEMBLY & INSTALLATION INSTRUCT IONS A. Introduction: SOLHARO ASSEMBLY & INSTALLATION INSTRUCT IONS Rev. 01/30/2012 The Solharo is an external, retractable, tensioned sun shading system designed to fit over a sunroom or wood pergola. The

More information

FEATURES & BENEFITS OF THE TOW PRO LITE :

FEATURES & BENEFITS OF THE TOW PRO LITE : To Protect & Preserve PRODUCT MANUAL & FITTING GUIDE tow pro lite TYPE: SEMI - FIT EACH TOW PRO LITE COMES WITH THE FOLLOWING : 16 side securing straps & buckles (8 either side) 1 HITCH STRAP & buckles

More information

Suggested Installation Instructions for: , Embroidered Front End Mask

Suggested Installation Instructions for: , Embroidered Front End Mask I I 1 Suggested Installation Instructions for: 602-246, 1975-1979 Embroidered Front End Mask 2-Cover Hooks 4-Air Foil Inserts 2-2" "U" Shaped Trim Locks 4-2" ADHESIVE BACKED Hook Strips 2-14" ADHESIVE

More information

OWNER S MANUAL: G5000 SLIDE-OUT AWNING SYSTEM

OWNER S MANUAL: G5000 SLIDE-OUT AWNING SYSTEM INSTALLATION, OPERATIONS, ADJUSTMENT AND REPAIR Rev. 08/01/12 1361 Calle Avanzado San Clemente California 92673 Office: (949) 259-4000 Toll Free: (800) 382-8442 Fax: (949) 276-5500 TABLE OF CONTENTS WARRANTY

More information

RCCK. Pivot Plug 2x. Sharp Screw 2x TAKE TIME - READ AND UNDERSTAND INSTRUCTIONS COMPLETELY!

RCCK. Pivot Plug 2x. Sharp Screw 2x TAKE TIME - READ AND UNDERSTAND INSTRUCTIONS COMPLETELY! RCCK Revolution Cargo Conversion Kit Congratulations on your purchase of the BOB Revolution Cargo Conversion Kit (RCCK). It s designed to easily convert your existing BOB Revolution stroller frame into

More information

Item # BJ2PC With 8 Leg Frame, Cover, and Enclosure Kit with Windows Size: 10 8 Wide x 20 Long (Side Height 6 8 ) (Center Peak Height 9 9 )

Item # BJ2PC With 8 Leg Frame, Cover, and Enclosure Kit with Windows Size: 10 8 Wide x 20 Long (Side Height 6 8 ) (Center Peak Height 9 9 ) Item # BJ2PC With 8 Leg Frame, Cover, and Enclosure Kit with Windows Size: 10 8 Wide x 20 Long (Side Height 6 8 ) (Center Peak Height 9 9 ) Powell & Powell Supply Company, L.L.C. Manufactured by: 1730

More information

IMPORTANT OWNER-OPERATOR INSTALLATION INSTRUCTIONS. Part # A7006

IMPORTANT OWNER-OPERATOR INSTALLATION INSTRUCTIONS. Part # A7006 IMPORTANT OWNER-OPERATOR INSTALLATION INSTRUCTIONS Part # A7006 Parts List Wobble Stopper Body Wobble Stopper Shaft Camper Bracket Lower Bracket Assembly Upper Bracket Upper Bracket Clamp 3/8 SAE Flat

More information

Solera Classic Awning OEM INSTALLATION MANUAL

Solera Classic Awning OEM INSTALLATION MANUAL Solera Classic Awning OEM INSTALLATION MANUAL TABLE OF CONTENTS System and Safety Information 2 Preparation 3 Resources Required 3 Installation 3 Installing the Awning Rail (If Necessary) 3 Assembling

More information

QuadraTop Bimini Top and Bimini Top Plus

QuadraTop Bimini Top and Bimini Top Plus QuadraTop Bimini Top and Bimini Top Plus Installation Manual for 87-95 Jeep YJ Wrangler Vehicles # 11022.0XXX and # 11022.101X TOP PLUS Loss of vehicle control involves risk of death or serious injury,

More information

OWNER'S MANUAL AWNING EXTEND R TABLE OF CONTENTS

OWNER'S MANUAL AWNING EXTEND R TABLE OF CONTENTS OWNER'S MANUAL AWNING EXTEND R RV Before operating the awning, carefully review the Owner's Manual. The manual contains important safety information, detailed operating instructions, common maintenance

More information

Installation Instructions Part # 2784 Awning

Installation Instructions Part # 2784 Awning Please read instructions entirely before installing this product. Parts Included Qty Parts Included Qty 1 Flat Washer (U-Bolt) 4 L Bracket 2 Nylock Nut ( U-Bolt) 4 Stake with Cord 2 6mm x 1 Bolt/Nut 10

More information

QuadraTop Clearview Windstopper

QuadraTop Clearview Windstopper QuadraTop Clearview Windstopper Installation Manual for 80-06 Jeep CJ, YJ & TJ Wrangler Vehicles # 11028.001X and # 11028.0135 FOR TJ WRANGLER FOR YJ WRANGLER Loss of vehicle control involves risk of death

More information

LODGE 460 CABIN. Part No ASSEMBLY & CARE INSTRUCTIONS

LODGE 460 CABIN. Part No ASSEMBLY & CARE INSTRUCTIONS LODGE 460 CABIN Part No. 920645 ASSEMBLY & CARE INSTRUCTIONS SPECIFICATIONS PRE USE Size: 460L x 360W x 240H cm Material: Heavy duty polycotton blend Walls: 250g/m2 Roof: 340g/m2 Windows: 6 Side & Rear

More information

Primrose Awnings - Standard Manual Instructions

Primrose Awnings - Standard Manual Instructions Primrose Awnings - Standard Manual Instructions Contents Warning 1.5m - 3.0m Awnings 4 x Expansion bolts (2 per bracket)** 2 x brackets 1 x Awning 1 x Winder handle 3.5m - 4m Awnings 6 x Expansion bolts

More information

ADDED PROTECTION FOR SLIDE-OUT ROOMS. Installation. Introduction... 2 Product Overview...2 Component Checklist...3

ADDED PROTECTION FOR SLIDE-OUT ROOMS. Installation. Introduction... 2 Product Overview...2 Component Checklist...3 CAREFREE SIDEOUT KOVER II RV Installation ADDED PROTECTION FOR SLIDE-OUT ROOMS TABLE OF CONTENTS SOKII Shown with Full Case Option Introduction... 2 Product Overview...2 Component Checklist...3 Installation...

More information

OWNER'S MANUAL CAMPOUT TABLE OF CONTENTS

OWNER'S MANUAL CAMPOUT TABLE OF CONTENTS OWNER'S MANUAL CAMPOUT RV Before operating the awning, carefully review the Owner's Manual. The manual contains important safety information, detailed operating instructions, common maintenance procedures

More information

FLEX KEY ASSEMBLY. ..._ o RAFTER ARM TUBE MAIN ARM TUBE CAP NUT CLAW HINGE

FLEX KEY ASSEMBLY. ..._ o RAFTER ARM TUBE MAIN ARM TUBE CAP NUT CLAW HINGE ZIP DEE Inc. 96 Crossen Ave. Elk Grove Village, IL 60007(847)437-0980 (800)338-2378 HEAD CASTING AWNING RAIL FLEX KEY ASSEMBLY..._ o GM1 Installation Instruction GMC Motorhome RAFTER ARM TUBE MAIN ARM

More information

PIONEER LITE PATIO AWNING OWNER'S MANUAL

PIONEER LITE PATIO AWNING OWNER'S MANUAL A Manual Crank Operated Awning RV OWNER'S MANUAL TABLE OF CONTENTS Introduction... 2 Operating the Awning... 3 To Open the Awning:... 3 Adjusting the Pitch... 4 Rain Release Setting... 4 Setting the Arms

More information

Cabinet Mount Assist Lift n Lock Instructions

Cabinet Mount Assist Lift n Lock Instructions Cabinet Mount Assist Lift n Lock Instructions PART LIST 2 @ Gas Cylinder 1 @ Lock Bar 2 @ Rubber Sleeve (preset) 4 @ Stopper Pin (2pcs preset) 4 @ Saddle Block 8 @ 19mm Black PVC Cap 5 @ 14mm Black PVC

More information

INSTRUCTION MANUAL ALEKO RETRACTABLE AWNING

INSTRUCTION MANUAL ALEKO RETRACTABLE AWNING INSTRUCTION MANUAL for ALEKO RETRACTABLE AWNING www.alekoproducts.com FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN PERSONAL INJURY! 1 Important Safety Precautions WARNING NOTE: FOR PERSONAL SAFETY,

More information

Owner s Manual Truck Bed Tent

Owner s Manual Truck Bed Tent Owner s Manual Truck Bed Tent Important! For safe and proper assembly, use, and care, read and follow all instructions. Everyone who uses this tent should first read this manual. 120810 www.kodiakcanvas.com

More information

14' x 32' x 12' Round Top Round Style Shelter Assembly Instructions

14' x 32' x 12' Round Top Round Style Shelter Assembly Instructions 14' x 32' x 12' Round Top Round Style Shelter Assembly Instructions Description Model # 14' x 32' x 12' RoundTop Garage - Gray 62669 Recommended Tools Please read instructions COMPLETELY before assembly.

More information

Assembly TOOLS REQUIRED: 17mm and 14mm or equivalent wrenches.

Assembly TOOLS REQUIRED: 17mm and 14mm or equivalent wrenches. Instructions for 3 Trimmer Rack, 3TR* *Patents Pending Assembly TOOLS REQUIRED: 17mm and mm or equivalent wrenches. 15 26 26 16 15 16 Attach the lower mounting brackets to the Trimmer Rack poles as shown

More information

Preparation. BEDRUG, INC. n 635 Old Hickory Blvd, Old Hickory, TN n n bedrug.com

Preparation. BEDRUG, INC. n 635 Old Hickory Blvd, Old Hickory, TN n n bedrug.com BRJK07F4, BRJK07F2, FRONT KITS: BTJK07F4, BTJK07F2 Jeep Wrangler JK BedRug/BedTred Interior Installation Instructions Congratulations on choosing the finest interior flooring kit available for your Jeep.

More information

Universal 10 x 27 Canopy

Universal 10 x 27 Canopy Universal 10 x 27 Canopy C81027PC Size: 10 8 x 27 x 6 8 (side) x 9 9 (center) With 10 Legs, Frame, and Cover Powell & Powell Supply Company Distributed by: 1730 Five Points Lane Fuquay-Varina, North Carolina

More information

Solera Classic Awning

Solera Classic Awning Solera Classic Awning OWNER'S MANUAL Page 1 Table of Contents System and Safety Information 2 Operation 3 Extending the Awning 3 Optional Car Port Position 3 Retracting the Awning 3 Fabric Replacement

More information

CAREFREE SL WINDOW AWNING MANUAL PULL DOWN WINDOW AWNING. Installation and Operations Manual r3 Printed in USA October, 2010

CAREFREE SL WINDOW AWNING MANUAL PULL DOWN WINDOW AWNING. Installation and Operations Manual r3 Printed in USA October, 2010 CAREFREE RV MANUAL PULL DOWN WINDOW AWNING Installation and Operations Manual 052533-001r3 Printed in USA October, 2010 PROPRIETARY STATEMENT The SL Window Awning is a product of Carefree of Colorado,

More information

PIONEER LITE PATIO AWNING

PIONEER LITE PATIO AWNING A Manual Crank Operated Awning RV OWNER'S MANUAL Before operating the awning, carefully review the Owner's Manual. The manual contains important safety information, detailed operating instructions, common

More information

Kontrol Kube Advanced Owners Manual

Kontrol Kube Advanced Owners Manual Mobile Containment. Simplified. TM Kontrol Kube Advanced Owners Manual KONTROL KUBE www.kontrolkube.com 800.343755 1 IMPORTANT SAFETY INFORMATION SAVE THESE INSTRUCTIONS. CAREFULLY READ AND FOLLOW THESE

More information

Wind Stopper Curtain for Jeep 2 Door JK & 4 Door JKU Wrangler Vehicles Items # and #

Wind Stopper Curtain for Jeep 2 Door JK & 4 Door JKU Wrangler Vehicles Items # and # MT_JK_WIND_S_INST_LTR_6.qxp_Layout 1 4/20/17 3:06 PM Page 1 Installation Instructions Wind Stopper Curtain for 2007-2018 Jeep 2 Door JK & 4 Door JKU Wrangler Vehicles Items #14400335 and #14400435 Wind

More information

Installation. Introduction... 2 Product Overview...2 Component Checklist...3

Installation. Introduction... 2 Product Overview...2 Component Checklist...3 CAREFREE SIDEOUT KOVER II RV WITH MANUAL LOCK Installation TABLE OF CONTENTS Introduction... 2 Product Overview...2 Component Checklist...3 Installation... 4 Installing the Mounting Brackets...4 Assemble

More information

INSTALLATION INSTRUCTIONS AND OWNER'S MANUAL AWNINGS. For trailers & motor homes with straight sides TOOLS REQUIRED

INSTALLATION INSTRUCTIONS AND OWNER'S MANUAL AWNINGS. For trailers & motor homes with straight sides TOOLS REQUIRED AWNINGS INSTALLATION INSTRUCTIONS AND OWNER'S MANUAL For trailers & motor homes with straight sides TOOLS REQUIRED 1/4" electric drill Ratchet handle kit 3/8" & 7/16" socket No. 1 and No. 2 screwdriver

More information

VACATION'R A ROOM FOR VERTICAL ARM AWNINGS

VACATION'R A ROOM FOR VERTICAL ARM AWNINGS VACATION'R A ROOM FOR VERTICAL ARM AWNINGS RV Made of durable, lightweight polyester material - the same material used for tents. Does not require hardware that is attached to the RV. No rafters to install.

More information

WARNING: IMPROPER INSTALLATION WILL RESULT IN LINER FLYING OUT OF THE TRUCK. FOLLOW INSTRUCTIONS EXACTLY

WARNING: IMPROPER INSTALLATION WILL RESULT IN LINER FLYING OUT OF THE TRUCK. FOLLOW INSTRUCTIONS EXACTLY Preparation Instructions Part Number(s): Multiple Kit Contents Item # Qty Req'd Description 1 1 BedTred Floor Panel 2 1 BedTred Bulkhead Panel 3 2 BedTred Sidewall Panels (L&R) 4 1 BedTred Tailgate Panel

More information

Core Systems Installation Instructions

Core Systems Installation Instructions 185-3017 185-3018 185-3517 607-0149 WLH 09/17/18 TABLE OF CONTENTS ***Assembly*** Roller Tube Assembly Roller Tube Assembly... Standard Application Attaching Tarp to Roller Tube - Standard... Installing

More information

Operation, Cleaning & Maintenance. For Aluminium Secondary

Operation, Cleaning & Maintenance. For Aluminium Secondary , Cleaning & Maintenance For Aluminium Secondary Contents Horizontal Sliders 3 Vertical Sliders - Non-Balanced 4 Vertical Sliders - Balanced 5 Vertical Sliders - Tilt Back 6-7 Lift Outs 8 Hinged Units

More information

Sunjoy D-DNC492PST 3-Seat Striped Adjustable Tilt Canopy. Wicker Metal Swing. Owner s Manual IMPORTANT

Sunjoy D-DNC492PST 3-Seat Striped Adjustable Tilt Canopy. Wicker Metal Swing. Owner s Manual IMPORTANT Sunjoy D-DNC492PST 3-Seat Striped Adjustable Tilt Canopy Wicker Metal Swing Owner s Manual IMPORTANT Thank you very much for choosing Sunjoy Group. Please take time to read these instructions thoroughly

More information

READ ME FIRST! IMPORTANT WARNING! ENG. Roof top tent

READ ME FIRST! IMPORTANT WARNING! ENG. Roof top tent Roof top tent ENG TENT031 220 min READ ME FIRST! Thank you for purchasing a Front Runner Roof Top Tent. Before you start, take a moment to familiarize yourself with these Fitting Instructions and the components

More information

10 X 20 X 8 Dome Canopy

10 X 20 X 8 Dome Canopy 10 X 20 X 8 Dome Canopy Warning Keep all flame and heat sources away from this tent fabric. Refer to labels for flamability specification. It is not fire proof. The tent fabric will burn if left in continuous

More information

INDEPENDENT SLIDE-OUT ROOM COVER AND AWNING

INDEPENDENT SLIDE-OUT ROOM COVER AND AWNING CAREFREE GUARDI-AWN RV INDEPENDENT SLIDE-OUT ROOM COVER AND AWNING Installation and Operation 052884-002r1 Printed in USA August, 2005 TABLE OF CONTENTS Introduction... 1 Product Overview...1 Product Specifications...1

More information

OUTBACK AWNING AND ROOM

OUTBACK AWNING AND ROOM OWNER'S MANUAL OUTBACK AWNING AND ROOM RV THIS BOOK CONTAINS ORIGINAL INSTALLATION AND SETUP 056500-001r1 Printed in USA May, 2007 TABLE OF CONTENTS Installing the Outback Awning... 1 Installing the Awning

More information

INSTALLATION SHEET-Ford Flareside ʻ97

INSTALLATION SHEET-Ford Flareside ʻ97 INSTALLATION SHEET-Ford Flareside ʻ97 Part Nos. 7615, 2615 DOUBLE HOOK Side Rail Clamps Cab Rail (BlackMax includes snaps on this rail) Spring Bows Tailgate Rail Side Rails Tarp Clamp Bolts U Shaped Clamps

More information

Vanagon Ladder Kit Assembly & Installation Instructions

Vanagon Ladder Kit Assembly & Installation Instructions Rocky Mountain Westy Vanagon Ladder Kit Assembly & Installation Instructions Introduction Thank you for purchasing the Rocky Mountain Westy Vanagon Ladder Kit. We pride ourselves in the products we develop

More information

INSTALLATION INSTRUCTIONS for folding arm awnings

INSTALLATION INSTRUCTIONS for folding arm awnings Custom made Awnings and Blinds Item No 0757 INSTALLATION INSTRUCTIONS for folding arm awnings IMPORTANT INFORMATION BEFORE INSTALLING YOUR Updated 08/09/15 AN AWNING INSTALLATION IS A HOME IMPROVEMENT

More information

QuadraTop Tonno Cargo Cover

QuadraTop Tonno Cargo Cover QuadraTop Tonno Cargo Cover Installation Manual for 87-06 Jeep YJ & TJ Wrangler Vehicles # 11051.0015, # 11051.011X, # 11051.02XX and # 11051.03XX FOR TJ WRANGLER FOR YJ WRANGLER Loss of vehicle control

More information

BRJK11F2, BTJK11F2, BRJK07F2, BTJK07F2, kit

BRJK11F2, BTJK11F2, BRJK07F2, BTJK07F2, kit BRJK11F2, BTJK11F2, BRJK07F2, BTJK07F2, FRONT KITS: BRJK07F4, BTJK07F4 Jeep Wrangler JK BedRug/BedTred Interior Installation Instructions Congratulations on choosing the finest interior flooring kit available

More information

RAM Installation Instructions: DR6 & DR7 TOOLS REQUIRED (2019-CURRENT, NEW BODY STYLE ONLY) FOLLOW #DECKEDUSA

RAM Installation Instructions: DR6 & DR7 TOOLS REQUIRED (2019-CURRENT, NEW BODY STYLE ONLY) FOLLOW #DECKEDUSA Installation Instructions: DR6 & DR7 RAM 1500 (2019-CURRENT, NEW BODY STYLE ONLY) TOOLS REQUIRED Adjustable wrench (that opens to about 1 ) 1/2 open end wrench #2 Phillip screwdriver 3/8 socket 7/16 deep

More information