NEWMAR SERVICE SCHOOL
|
|
- Heather Dawson
- 5 years ago
- Views:
Transcription
1 NEWMAR SERVICE SCHOOL TRAINING INFORMATION GUIDELINE FOR FEBRUARY 2013
2 OUR PRODUCTS: NOVA DUAL PITCH AWNING G-2000/ G P a g e
3 G-2085 G P a g e
4 G-LINKS 4 P a g e
5 NOVA/ G-2000/ G-1500 BASIC ADJUSTMENTS A. ADJUSTING MOTOR LIMIT SWITCHES NOTE: The motor limit switches have been adjusted to the correct position at the factory prior to shipment. The awning motor is set to stop the exact moment the awning box closes. The fabric should be taut, the arms should be slightly bent, exposing a 1/4 gap at the elbows. Always check the motor limits after installation to ensure that the awning opens and closes correctly. Awning fabric can stretch over time, this will require an adjustment of the OUT limit switch. IMPORTANT: EXTREME CARE SHOULD BE TAKEN TO ENSURE THAT THE MOTOR LIMIT TURNS OFF AT THE EXACT MOMENT THE AWNING BOX CLOSES. FAILURE TO DO SO WILL CAUSE THE MOTOR TO RUN WHEN THE AWNING IS CLOSED. THIS CAN SUBSTANTIALLY REDUCE THE LIFE OF THE MOTOR. 1. The AC motors used in Girard Systems awnings are reversible. Any reference made to the motor limit switches in these instructions are based on the right-hand placement of the motor. For left hand placement, simply reverse the instructions. (Figure 8) 2. The motor has limit settings for both OUT (extension) and IN (retraction). 3. Adjust the limit switches with the black key provided with the awning, or you may use a 4mm (5/32 ) allen wrench. 4. Extend the awning a few feet to gain access to the motor. Locate the motor (standard installation is on the right hand side of the awning). The limit adjustment holes are located on the head of the motor. Using the symbols printed next to the adjustment holes, turn the black key (or 4mm allen wrench) to make the necessary adjustments. Typically, the motors are labeled with a (+) or a (-). (Figure 9) 5 P a g e
6 1. (Figure 9) 5. Approximately ¼ turn of the adjustment screws represents about 1 of awning movement. NEVER set outward limits so that the fabric is slack with full arm extension. For proper adjustment set limit switch to stop the motor just before the arms lock. This will expose about an 1/4 gap at the elbow. B. ADJUSTING PITCH and ARM (Elbow) HEIGHTH NOTE: This adjustment is usually required after an arm replacement. Also, when the elbow of the arm hits the bottom of the casing as the lead rail closes. Tools Required 19mm (3/4 ) open-end wrench 6 P a g e
7 10mm (3/8 ) open-end wrench A. ELBOW HEIGHTH 1. Extend the awning about On the selected arm, loosen the two(2) nylon nuts on the side of the upper arm connection (shoulder), using a 19mm open-end wrench. 3. Locate the smaller adjustment bolt located directly below the rear lock nut loosened in step #2. (Figure 10) Using a 10mm open-end wrench rotate the bolt clockwise to TIGHTEN and raise the arm location inside the cassette. Rotate the bolt counter-clockwise to LOOSEN or lower the arm location inside the cassette. 4. NOTE: After retightening the nylon nuts, the arms will raise slightly higher. 5. Tighten the two(2) nylon nuts located on the side of the upper arm connection. 6. Close the awning completely to ensure a proper fit. Loosen front bolt Pivot bolt Adjustment bolt Arm elevator screw (Figure 10) B. ADJUSTING PITCH NOTE: Your NOVA Awning will have the pitch adjusted to its highest point. DO NOT TRY TO RAISE THE PITCH, this could result in damaging the awning. 1. Extend the awning about P a g e
8 2. On the arm selected, loosen the two(2) nylon nuts on the upper side of the arm connection using a 19mm open-end wrench. 3. Locate the larger adjustment bolt located on the bottom of the upper arm connection (shoulder). (Figure 11) Using a 19mm open-end wrench rotate the bolt counter-clockwise to LOOSEN or lower the pitch. If the pitch is lowered too far you may turn the bolt clockwise or TIGHTEN to raise the pitch. DO NOT OVERTIGHTEN. 4. Tighten the two(2) nylon nuts located on the side of the upper arm connection. 5. Close the awning completely to ensure a proper fit. Adjustment bolt (Figure 11) C. TESTING THE ANEMOMETER (Wind Sensor) 1. Partially extend the awning. 8 P a g e
9 2. Manually employ the anemometer by blowing on the cups or by spinning them. 3. At this point the awning should retract; if not, check motor connection for proper polarity. NOTE: The Anemometer will send a retract signal to all of the awnings installed on the RV. The power system of the vehicle must be able to withstand the resulting surge of current. The surge will be the greatest when the awnings are fully extended. When testing the system verify all of the awnings will close when fully extended. If the system does not operate correctly under these conditions you may: A. Provide sufficient power from your panel. B. Replace the anemometer in the electronics system with a Motion Sensor. D. ADJUSTING THE LEAD RAIL 1. The lead rail on your awning has been preset from the factory at +/- 3 degrees. This allows the lead rail to rest firmly into the cassette and also creates a weather resistant seal for travel. To increase or decrease the pitch angle insert a 5mm allen wrench into the top pitch-angle screw. Turn clockwise to increase the pitch and turn counterclockwise to decrease the pitch. (Figure 12) Lead rail Pitch-angle screw Tension plate Horizontal lead rail adjustment screw (Figure 12) 9 P a g e
10 G-5000 BASIC ADJUSTMENTS SPRING TENSION ADJUSTMENT The tension of the Torsion Spring is preset at the factory between 7 and 8 full turns. 1. To adjust the tension, facing the G5000, gently remove the left end (LH) plastic cap. 2. Attach Girard Tension Tool to 3/8 rachet. Insert tension tool in to square tube. Maintain tension on spring. Proceed to remove two center screws. 3. NOTE: Use caution when removing the two (2) center screws (#22) on the slide plate: The spring is under tension and may cause the ratchet to turn violently inflicting injury. 4. Hold the ratchet handle tight as you remove part the two center screws from the spring support and carefully release all tension. Use channel locks on the special tool to maintain the tension while repositioning the ratchet handle. 5. Now you are ready for tensioning. Take up fabric slack. Apply 7 full turns, or 14 half turns (follow arrows on end plate to tension). 6. Awnings of widths greater than 244 inches (G5000 Super-slide) are equipped with two (2) springs (one at each end). In this case, you will also need to adjust the tension of the second spring (right hand) (in this case clockwise more tension, counter-clockwise less tension). 7. Replace the screws and plastic end cap. SPRING REPLACEMENT 1. Facing the G5000, take care and remove the plastic end cap. 2. Attach Girard Tension Tool to 3/8 ratchet. Insert tension tool in to square tube. Maintain tension on spring. Proceed to remove two center screws. 10 P a g e
11 3. NOTE: Use caution when removing the two (2) center screws (on slide plate. The spring is under tension and will cause ratchet to turn violently. 4. Hold the ratchet handle tight as you remove the two center screws from the spring support, and carefully release all tension. Use channel locks on the tension tool to maintain the tension while repositioning the ratchet handle. 5. Remove the three remaining screws from the metal side plate. 6. Pull defective spring assembly out of roller tube and insert replacement spring with the drive (stationary fitting) first. 7. Once spring is reinserted reinstall the retaining screws into the cassette. 8. Now we are ready for tensioning. Take up fabric slack. Apply 7 full turns, or 14 half turns (follow arrows on end plate to tension). 9. Re-attach center screws into spring support while maintaining tension. 10. Replace the end cap. G-2085 BASIC REPAIRS AND ADJUSTMENTS SETTING MOTOR LIMITS 1. Adjust the limit switches with the black plastic key (provided) or a 4mm Allen wrench. 2. Extend the awning a few feet and locate the cylindrical awning motor mounted inside the awning roller tube, standard installation is at the right/front end of the awning). The limit switches are mounted on the black casing at the exposed end of the motor. The limit switches are two directional arrows, each with a plus (+) sign and a minus (-) sign. The actual limit switch is the recessed hole next to the corresponding arrow. 11 P a g e
12 3. Adjust limits according to the directional arrows). A 1/4 turn represents approximately 1" of awning movement. Never set outward limits so that fabric is slack after full arm extension. Adjust limit switches until the motor stops at the exact time that the arms reach a 90 ANGLE with the coach wall. FABRIC CHANGE 1. Relieve the tension from fabric by (+) the out limit until the roller tube is exposed and fabric hangs straight down. 2. Remove lead rail end caps (both sides)and housing end cap opposite of motor and fabric screws on both sides of the lead rail. 3. Remove old fabric and insert new fabric. This operation is completed much easier with two people. 4. Close awning making sure fabric is rolling up straight evenly spaced on both sides of tube. Apply gentle pressure to both sides of the fabric as it rolls up. 5. Open awning about 1/2 way, then (-) the out limit to set the awning back to its original 90 degree position. 6. Re-attach fabric screws and lead rail caps and the housing cap. G-LINK SYSTEM OVERVIEW AND PROGRAMMING GC-136 PROGRAMMING NOTE: Before starting this procedure the Receiver must be without power (OFF) for at least 10 seconds. During the programming function the interval between each step required must be less than 10 seconds. A. Programming the GC136 to a Remote 1. Turn on the power to the GC P a g e
13 2. Press the PROGRAM button using a paper clip or other small tool: the Green LED will start blinking. 3. Press STOP The Green LED will stop blinking and stay on solid. 4. Press the UP button on the REMOTE (Control or Unit): The Green LED will turn off. B. Cancel one Remote from the GC Turn on the power to the GC Press the PROGRAM button (Fig. 2) using a paper clip or other small tool: the Green LED will start blinking. 3. Press STOP (Fig. 1): The Green LED will stop blinking and stay on solid. 4. Press the DOWN button on the REMOTE (Unit): The Green LED will turn off. C. Delete all of the Remotes from the GC Turn on power to GC Verify which Button of the GC136 functions as DOWN button (Opens the Awning). 3. Press simultaneously the STOP and DOWN button of the GC136 for at least 6 seconds: The Green LED will first turn on solid and then blink a few times. When the Green LED turns off the operation is completed. D. Program Continuous or Step mode of operation 1. Turn on power to GC Verify which Button of the GC136 functions as UP button (Closes the Awning). 3. Press simultaneously the STOP and UP button of the GC136 for at least 6 seconds: The Green LED will first turn on solid and then blink a few times. When the Green LED turns off the operation is completed. 12V MOTION SENSOR PROGRAMMING A. Programming the GC779G to the (GC136) 1. Power the GC779G to a 12volt DC circuit. 2. Set the Adjustment Dial to level P a g e
14 3. Press the PROGRAM button on the GC136 (The green LED will start blinking). 4. Press the STOP button on the GC136 (The green LED will stay solid). 5. Place the unit on the base (attached to the Lead Rail) so that the Reed Switch (see Picture 2) is in close proximity with the magnet on the base (the purple LED will light). 6. Press the PROGRAM button on the GC779G. 7. Test if the code was accepted by pressing again the push button on the GC779G (The Awning should retract). 8. If the Awning does not retract start over again. 9. Bring back the Black Dial to the desired sensitivity number (level 3 is the factory setting. ANEMOMETER PROGRAMMING A. Programming the GC116I to a GC-136 Receiver 1. Turn on the GC-136 and the GC116I (Leave them on if already on). 2. Press the PROGRAM button on the GC-136 (the LED will start blinking). 3. Press the STOP button on the GC-136 (The LED will be on solid). 4. Press the UP button on the GC116I. 5. Extend awing using a Manual Remote Control and press again the UP button on the GC116I to verify that the unit is working properly (the awning should Retract). GC 104 AND 105A PROGRAMMING A. PROGRAMMING THE REMOTE CONTROLS TO A RECEIVER 1. Select on the GC105A the desired Channel, GC104 is single channel. 2. Make sure that the Receiver (GC136) is powered on. 3. Press the PROGRAM button on the Receiver: the Green LED of the Receiver will start blinking. 4. Press STOP on the Receiver: The Green LED will stop blinking and stay on solid. 5. Press the UP button on the GC106: The Green LED will turn off. 14 P a g e
15 GC 229 AND 230 PROGRAMMING A. To Program GC229 OR GC230 to a GC-136 Receiver 1. Turn on the GC-136 (Leave it on if already on). 2. Press the PROGRAM button on the GC-136 (the LED will start blinking). 3. Press the STOP button on the GC-136 (The LED will be on solid). 4. Press the desired UP button on the GC229 OR GC Extend or Retract the awning to verify that the unit is working properly. THIS CONCLUDES THE BRIEF OVERVIEW OF SOME OF GIRARD SYSTEMS PRODUCTS. PLEASE CONSULT THE CD COPY OF THE MANUALS FOR ANY INFORMATION NOT COVERED IN THIS HANDOUT. FOR ANY OTHER TECHNICAL SERVICE QUESTIONS PLEASE FEEL FREE TO CALL GIRARD SYSTEMS SERVICE LINE MONDAY THROUGH FRIDAY 7AM TO 5PM PST. THE TOLL FREE NUMBER IS (800) P a g e
16 16 P a g e
OWNER S MANUAL: G5000 SLIDE-OUT AWNING SYSTEM
INSTALLATION, OPERATIONS, ADJUSTMENT AND REPAIR Rev. 08/01/12 1361 Calle Avanzado San Clemente California 92673 Office: (949) 259-4000 Toll Free: (800) 382-8442 Fax: (949) 276-5500 TABLE OF CONTENTS WARRANTY
More informationRETRACTABLE AWNING w/ OPTIONAL HOOD ASSEMBLY INSTRUCTIONS
Contact us @ (800)851-0865 RETRACTABLE AWNING w/ OPTIONAL HOOD ASSEMBLY INSTRUCTIONS Congratulations on your purchase of a new retractable awning. With proper installation this awning will provide years
More information12V MOTION SENSOR 98GC779G INSTALLATION & PROGRAMMING GUIDE REV RV AWNING PRODUCTS
12V MOTION SENSOR 98GC779G INSTALLATION & PROGRAMMING GUIDE REV.07242015 RV AWNING PRODUCTS 1361 CALLE AVANZADO, SAN CLEMENTE, CA 92673 (800) 382-8442 FAX (949)276-5500 www.girardrv.com Girard Systems
More informationVISION PATIO AWNING INSTALLATION GUIDE. Rev RV AWNING PRODUCTS
VISION PATIO AWNING INSTALLATION GUIDE Rev. 042015 RV AWNING PRODUCTS 1361 CALLE AVANZADO, SAN CLEMENTE, CA 92673 (949) 259-4000 FAX (949)276-5500 WWW.GIRARDRV.COM Girard Systems awnings may be operated
More informationAWNING CONTROL KIT 98GCK-33B
AWNING CONTROL KIT 98GCK-33B REV.07282015 RV AWNING PRODUCTS 1361 CALLE AVANZADO, SAN CLEMENTE, CA 92673 (800) 382-8442 FAX (949)276-5500 www.girardrv.com AC MOTOR CONTROL MODULE GC274B INSTALLATION and
More informationRoller Bar End Cap (w/round Drive Shaft) Replacement Instructions for Vista and Motorized Awnings * Helpers needed *
RETRACTABLE AWNINGS For Technical Support visit us at www.sunsetter.com/ownerscorner or Call Toll Free 800-670-7071 Fax 877-224-4944 Roller Bar End Cap (w/round Drive Shaft) Replacement Instructions for
More informationquick and easy installation guide
www.directdriveopener.com quick and easy installation guide Back 2 Front. Motor Carriage 2. C-rail. Chain. Limit stops. Slide in part (tensioner) Rail assembly Insert C-rail parts () into the connecting
More informationInstallation Instructions for the Rolltec Bravo Awning
Installation Instructions for the Rolltec Bravo Awning Questions? Call Rolltec at 1-800-667-0474 Table of Contents Available installation brackets Side dimensions of various installations Determining installation
More informationInstallation Instructions for the Rolltec Adalia X3M Extenda Awning
Installation Instructions for the Rolltec Adalia X3M Extenda Awning Questions? Call Rolltec at 1-800-667-0474 General Tool Requirements Table of Contents Available installation brackets Side dimensions
More informationINSTRUCTION MANUAL ALEKO RETRACTABLE AWNING
INSTRUCTION MANUAL for ALEKO RETRACTABLE AWNING www.alekoproducts.com FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN PERSONAL INJURY! 1 Important Safety Precautions WARNING NOTE: FOR PERSONAL SAFETY,
More informationFLEX KEY ASSEMBLY. ..._ o RAFTER ARM TUBE MAIN ARM TUBE CAP NUT CLAW HINGE
ZIP DEE Inc. 96 Crossen Ave. Elk Grove Village, IL 60007(847)437-0980 (800)338-2378 HEAD CASTING AWNING RAIL FLEX KEY ASSEMBLY..._ o GM1 Installation Instruction GMC Motorhome RAFTER ARM TUBE MAIN ARM
More informationINSTALLATION INSTRUCTIONS AND OWNER'S MANUAL AWNINGS. For trailers & motor homes with straight sides TOOLS REQUIRED
AWNINGS INSTALLATION INSTRUCTIONS AND OWNER'S MANUAL For trailers & motor homes with straight sides TOOLS REQUIRED 1/4" electric drill Ratchet handle kit 3/8" & 7/16" socket No. 1 and No. 2 screwdriver
More informationPrimrose Awnings - Full Cassette Manual & Electric Instructions
Primrose Awnings - Full Cassette Manual & Electric Instructions Contents Warning 2.0m - 3.5m Awnings 8 x Expansion bolts ** 2 x brackets 1 x Awning 1 x Winder 4.0m - 5.0m Awnings 12 x Expansion bolts **
More informationALEKO Victoria Series Retractable Awning Instructions for Installation and Operation
www.alekoproducts.com ALEKO Victoria Series Retractable Awning Instructions for Installation and Operation PLEASE DO NOT RETURN THIS PRODUCT TO THE STORE! The owner s manual includes assembly and operating
More informationAND LOAD CANOPY RACK SPECIFICATIONS
8MAY15 INSTRUCTIONS for the LOCK AND LOAD CANOPY RACK SPECIFICATIONS and SAFE LOADING REQUIREMENTS The Lock and Load ladder carrier for Truck Caps is a rack designed to mount to the top of a pickup truck
More informationContents. Awnings USA - Full Protective Hood Manual Instructions ft 11" - 11ft 6" Awnings
Awnings USA - Full Protective Hood Manual Instructions Contents Warning We recommend that two or more people are required to lift the awning into place. 4ft 11" - 11ft 6" Awnings 8 x Expansion bolts **
More informationVEPR Round Drum Disassembly and Assembly
VEPR 12 25 Round Drum Disassembly and Assembly Required Tools ¼ Allen Wrench Flat Head Screwdriver Drum Parts List Drum Body Carousel Center Bolt Dummy Rounds Carousel Lock Spring Clear Drum Cover Step
More informationInstallation Instructions for the Rolltec Physique XL Awning
Installation Instructions for the Rolltec Physique XL Awning Questions? Call Rolltec at 1-800-667-0474 General Tool Requirements Table of Contents Available installation brackets Side dimensions of various
More informationWireless Wind Sensor Installation and Operation Instructions
WARNINGS: RETRACTABLE AWNINGS For Technical Support visit us at www.sunsetter.com/ownerscorner or Call Toll Free 800-670-7071 Fax 877-224-4944 Wireless Wind Sensor Installation and Operation Instructions
More informationG-2000 PATIO AWNING G-1500 DOOR AWNING
G-2000 PATIO AWNING G-1500 DOOR AWNING INSTALLATION, OPERATION, ADJUSTMENT and REPAIR REV.01272016 RV AWNING PRODUCTS 1361 CALLE AVANZADO, SAN CLEMENTE, CA 92673 (800) 382-8442 FAX (949)276-5500 www.girardrv.com
More informationfunctionality with the necessary maintenance tools stored in a convenient built in tool box, as well as parallel handles for
GuilloMax User Manual The Guillomax has distinct features such as its unique structure and ease of cutting. It combines symmetry with functionality with the necessary maintenance tools stored in a convenient
More informationPrimrose Awnings Half Cassette Manual & Electric Instructions
Primrose Awnings Half Cassette Manual & Electric Instructions Contents for 2.5m, 3m Awnings 4 x Expansion bolts (2 per bracket)** 2 x brackets 1 x Awning Contents for 3.5m, 4m Awnings 6 x Expansion bolts
More informationPrimrose Awnings Full Cassette Manual & Electric Instructions
Primrose Awnings Full Cassette Manual & Electric Instructions Contents for Full Cassette Awning 1 x Remote control receiver box 2 x Remote hand-held zappers 1 x 5 metre cable 1 x Template sticker **The
More informationSOLHARO ASSEMBLY & INSTALLATION INSTRUCT IONS
A. Introduction: SOLHARO ASSEMBLY & INSTALLATION INSTRUCT IONS Rev. 01/30/2012 The Solharo is an external, retractable, tensioned sun shading system designed to fit over a sunroom or wood pergola. The
More informationGirard Systems- Warranty and Freight Procedures
Girard Systems- Warranty and Freight Procedures Return Policy Authorization must be obtained from Girard prior to the return of any merchandise for repair, replacement or credit. The purchaser should obtain
More informationSolera Classic Awning
Solera Classic Awning OWNER'S MANUAL Page 1 Table of Contents System and Safety Information 2 Operation 3 Extending the Awning 3 Optional Car Port Position 3 Retracting the Awning 3 Fabric Replacement
More informationPLATINUM MODEL WITH AUTO-RETRACT AND REMOTE CONTROL. Owner s Manual
PLATINUM MODEL WITH AUTO-RETRACT AND REMOTE CONTROL Owner s Manual THIS MANUAL CONTAINS INSTRUCTIONS FOR UPGRADING BOTH THE GOLD MODEL ONE-TOUCH AND THE ONE-TOUCH MODEL WITH THE KEY SWITCH TO THE PLATINUM
More informationMIRAGE 2-STAGE AWNING
SERVICE MANUAL MIRAGE 2-STAGE AWNING RV Read this manual before installing or using this product. Failure to follow the instructions and safety precautions in this manual can result in personal injury
More informationUser s Manual Trampoline 8
User s Manual Trampoline 8 Model! WARNING Read all precautions and instructions in this manual before using this equipment. Save this manual for future reference. Maximum user weight 17 lbs. ASSEMBLY IMPORTANT
More informationCassette-folding arm-awning markilux 990
Cassette-folding arm-awning markilux 990 Mounting instructions 1. Overview 1 Projection profile 2 Folding arm 3 Fabric 4 Console 5 Cassette 6 Covering cap 7 Wall bracket 2. Mounting brackets 2.1 Overview
More informationMotorized Oasis Awning RTS Motor Cord Replacement Instructions *Helpers Needed*
RETRACTABLE AWNINGS For Technical Support visit us at www.sunsetter.com/ownerscorner or Call Toll Free 800-670-7071 Fax 877-224-4944 Motorized Oasis Awning RTS Motor Cord Replacement Instructions *Helpers
More informationRETRACTABLE PATIO SHADE AWNING Patio Awning Guide-10ft. x12ft.(proj. X Width) Model: APR ***/APR (version: GEN2-V1)
Page 1 of 14 RETRACTABLE PATIO SHADE AWNING Patio Awning Guide-10ft. x12ft.(proj. X Width) Model: APR-101012***/APR-60021012 (version: GEN2-V1) WARNING: DO NOT CUT THE PLASTIC ZIP TIES ON THE AWNING EXTENSION
More informationINSTRUCTIONS INSTALLATION UNIVERSAL SERIES PATIO AWNING HARDWARE , , ,
RECORD THIS INFORMATION FOR FUTURE REFERENCE: Model Number Serial Number Hardware Model Number Hardware Serial Number Date Purchased Retailer / Qualified Installer INSTALLATION INSTRUCTIONS UNIVERSAL SERIES
More informationPrimrose Awnings Half Cassette Manual & Electric Instructions
Primrose Awnings Half Cassette Manual & Electric Instructions Contents Contents for 2m, 2.5m, 3m Awnings 2 x wall brackets 4 x expansion bolts (2 per bracket)** 1 x Awning Contents for 3.5m, 4m and 4.5m
More informationPLATINUM MODEL WITH AUTO-RETRACT AND REMOTE CONTROL. Owner s Manual
PLATINUM MODEL WITH AUTO-RETRACT AND REMOTE CONTROL Owner s Manual THIS MANUAL CONTAINS INSTRUCTIONS FOR UPGRADING BOTH THE GOLD MODEL ONE-TOUCH AND THE ONE-TOUCH MODEL WITH THE KEY SWITCH TO THE PLATINUM
More informationRetractable Awning Owner s Manual
Retractable Awning Owner s Manual TABLE OF CONTENTS SECTION-1 2 CONGRATULATIONS ON PURCHASE 2 OPERATING YOUR SHADELINE AWNING 2 GEAR CRANK OPERATION 2 EXTENDING YOUR AWNING 2 RETRACT 2 SECTION-2 3 MOTORIZED
More information, & Series Nested Hardware
RECORD THIS INFORMATION FOR FUTURE REFERENCE BEFORE INSTALLING THE UNIT: Model Number Serial Number Date Purchased Place of Purchase USA SERVICE OFFICE Dometic Corp. 509 So. Poplar St. LaGrange, IN 46761
More informationSERVICE MA M NUAL MIRAGE 2-STAGE AWNNING
M MIRAG GE 2-S SERVICE MANUAL STAGE AWNING RV e adjustments and repairs described in this book should be performed by trained technicians at Authorized Carefree Dealerships. Work performed by non-authorized
More informationAdvantage Plus TIM-3600 Series Reel
Read the following precautions and instructions before you begin assembly or using. Failure to comply with these instructions could result in personal injury or property damage. Keep these instructions
More informationUrea/Adblue Hose Reel
www.scintex.com.au sales@scintex.com.au Model: SHR3408 Urea/Adblue Hose Reel Product Manual Specifications Spring driven drum: for automatic rewind. Locking ratchet: to maintain the desired length of hose
More informationG-2085 AUTOMATIC WINDOW AWNING SYSTEM Operating and Installation Manual
G-2085 AUTOMATIC WINDOW AWNING SYSTEM Operating and Installation Manual 2004 WARNING: improper installation, adjustment, alteration, service, or maintenance can cause injury or property damage. Carefully
More informationWIDESPREAD LAVATORY MODELS WITH HI-ARC SPOUT
5951, 5961, 5981, 5983, 5993 SERIES MT122B INSTALLATION INSTRUCTIONS THESE INSTRUCTIONS MUST BE LEFT WITH HOMEOWNER WIDESPREAD LAVATORY MODELS WITH HI-ARC TRADITIONAL CROSS NOTE: Handle Inserts are not
More informationRETRACTABLE PATIO SHADE AWNING Patio Awning Guide-10ft. x14ft.(proj. X Width) Model: AP (version: GEN2-V1)
Page 1 of 14 RETRACTABLE PATIO SHADE AWNING Patio Awning Guide-10ft. x14ft.(proj. X Width) Model: AP021014 (version: GEN2-V1) WARNING: DO NOT CUT THE PLASTIC ZIP TIES ON THE AWNING EXTENSION ARMS UNTIL
More informationRAFTER VI. Installation and Operation CAREFREE WITH AUTOMATIC AWNING SUPPORT. RV Accessory PRODUCT OVERVIEW
CAREFREE RAFTER VI RV Accessory WITH AUTOMATIC AWNING SUPPORT Installation and Operation PRODUCT OVERVIEW The gives the awning user the ability to easily tighten the center fabric when the awning is extended.
More informationTUCSON PATIO AWNING INSTALLATION MANUAL
TUCSON PATIO AWNING INSTALLATION MANUAL Toll Free 877-792-1775 Fax 877-792-0031 swsuncontrolpro.com sales@swsuncontrol.com 1 INTRODUCTION...3 1.1 Symbols used in this manual... 3 1.2 Personnel requirements...
More informationOWNER S TECHNICAL MANUAL
OWNER S TECHNICAL MANUAL Heavy Duty Oil Hose Reel 504200 Description Open hose reel for air, water (high or low pressure), oil or grease, depending on model. Uncoil the hose to the desired length. It can
More informationWenger Corporation 2014 Printed in USA 05/14 Part #049B015-09
Assembly Instructions Tuba Tamer Contents Important User Information...........................2 Replacemant Parts List..............................3 Assembly.........................................4
More informationModel INSTALLATION INSTRUCTIONS
RECORD THIS UNIT INFORMATION FOR FUTURE REFERENCE: Model Number Serial Number Date Purchased USA SERVICE OFFICE Dometic, LLC 2320 Industrial Parkway Elkhart, IN 46516 574-294-2511 895(X)0(X)1.400(X) Basement
More informationInstallation and User s Manual 12 x 10 MOTORIZED AWNING
12 x 10 MOTORIZED AWNING Installation and User s Manual 12 x 10 MOTORIZED AWNING 088-1763-0 Stop Please read and understand this manual before any assembly or use of this product. Before beginning assembly
More informationSolera Classic Awning OEM INSTALLATION MANUAL
Solera Classic Awning OEM INSTALLATION MANUAL TABLE OF CONTENTS System and Safety Information 2 Preparation 3 Resources Required 3 Installation 3 Installing the Awning Rail (If Necessary) 3 Assembling
More informationTWISTLOCK VEHICLE STABILIZER (TVS) SYSTEM INSTRUCTIONS
TWISTLOCK VEHICLE STABILIZER (TVS) SYSTEM 22-797010, 22-797020, 22-796161 INSTRUCTIONS COMPONENTS: 1. TVS-100, PN 22-797010: 47 60 (119 cm 152 cm) stroke TwistLock Vehicle Stabilizer. Component weight,
More informationModel 205 Fireview Maintenance Kit
Model 205 Fireview Maintenance Kit Please read all of the instructions before you begin the procedure. Confirm that you have all the necessary tools and parts required. Allow about one hour to complete
More information/ Tool and Equipment Safety Tether System (T.E.S.T.S)
20 INSTRUCTIONS FOR USE AND PRODUCT GUIDE 799953 / 799955 Tool and Equipment Safety Tether System (T.E.S.T.S) Part # T353012 Rev 2 Reliance Industries LLC 2802 East X Street Deer Park, Texas 77536 281-930-800
More informationHANDLES AND CONTROL CABLES
Worm Drive Transmission........................ 1 Single Speed Spur/Bevel Gear Transmission............. Single Speed Bevel Gear Transmission................ Three Speed Transmission.......................
More informationOtter Pro XT Cabin Installation and Set-Up Instructions
Otter Pro XT Cabin Installation and Set-Up Instructions Otter Pro XT Cabin Fits Medium Otter Pro and Otter II Sled Only Parts Identification and Check List MODEL NUMBERS: Complete Pkg Pro XT Thermal Cabin
More informationProduct instruction manual Ream Cutting Systems RE3943, RE3946, RE3947, RE3971, RE3952E
Product instruction manual Ream Cutting Systems RE3943, RE3946, RE3947, RE3971, RE3952E The Trimfast Ream Cutters are reliable, high performance cutters that will give you the results you need quickly
More informationOptional Controls (Depends which set was purchased) Set A (Remote control kit)
Primrose Awnings - Full Cassette Manual & Electric Instructions Contents Warning 1.5m - 3.5m Awnings 8 x Expansion bolts ** 2 x brackets 1 x Awning 1 x Winder 4.0m - 5.0m Awnings 12 x Expansion bolts **
More informationInstallation manual. Awning. V480 Cannes
Installation manual Awning V480 Cannes Installation manual awning V480 Cannes Content 1. Awning * 2. Wall supports 3. Extra support(s) (with an awning bigger than 350 cm) 4. Mounting plates (optional)
More informationOWNER'S MANUAL MIRAGE
OWNER'S MANUAL MIRAGE RV MANUAL AND 110VAC MOTORIZED AWNING TABLE OF CONTENTS Introduction... 2 Operation... 3 Standard Switch Operation... 3 Wind-Sensor Auto Retract... 3 Setting the Wind Speed Sensitivity...
More informationINSTALLATION INSTRUCTIONS for folding arm awnings
Custom made Awnings and Blinds Item No 0757 INSTALLATION INSTRUCTIONS for folding arm awnings IMPORTANT INFORMATION BEFORE INSTALLING YOUR Updated 08/09/15 AN AWNING INSTALLATION IS A HOME IMPROVEMENT
More informationAssembly. Step 3. Attach the safety bracket (7) to the Pivot ARM (6).
Assembly Step 1. A. Stand the base of the machine by separating the U-frames (1,2). Pull the Front and Rear U-Frames (1,2) as far apart from each other as possible. Then push down on the middle of the
More informationOWNER'S MANUAL FREEDOM WMNL AWNING MOTORIZED OR MANUAL LATERAL ARM BOX AWNING
OWNER'S MANUAL FREEDOM WMNL AWNING MOTORIZED OR MANUAL LATERAL ARM BOX AWNING RV Before operating the awning, carefully review the Owner's Manual. The manual contains important safety information, detailed
More informationModel. Oasis Automatic and Manual RV Door Awning System INSTALLATION & OPERATING INSTRUCTIONS
Oasis Automatic and Manual RV Door Awning System USA SERVICE OFFICE Dometic Corp. 509 So. Poplar St. LaGrange, IN 46761 260-463-4858 CANADA Dometic Dist. 866 Langs Dr. Cambridge, Ontario CANADA N3H 2N7
More informationULTRA SLIDE OUT AWNING
ULTRA SLIDE OUT AWNING SG5000 INSTALLATION GUIDE REV.01262016 RV AWNING PRODUCTS 1361 CALLE AVANZADO, SAN CLEMENTE, CA 92673 (800) 382-8442 FAX (949)276-5500 www.girardrv.com Girard Systems awnings may
More informationGenesis. Side Burner Accessory Installation. Step 3. Step 1. Step 2. For use with Genesis Gas Barbecues Only
Genesis Side Burner Accessory Installation For use with Genesis Gas Barbecues Only Step 1 WARNING: All gas controls and supply valves should be in the OFF position. You will need: Side burner assembly
More informationTITAN Fuel Tanks. INSTALLATION INSTRUCTIONS G e n e r a t i o n V
TITAN pt. no.: 02 0000 0128 Important: Please read these instructions carefully and completely before starting the installation. TITAN Fuel Tanks INSTALLATION INSTRUCTIONS G e n e r a t i o n V Extended
More informationLM601 Landmark Permanent Blind
LM601 Landmark Permanent Blind Get parts online at www.huntriversedge.com P/N: 26742 REV1: 01/13/17 2017 RETI All Rights Reserved INTRODUCTION Landmark Permanent Blinds are engineered with you the hunter
More informationThese instructions apply to all models listed. Procedures unique to a specific model are labeled appropriately.
SERVICE MANUAL MIRAGE RV MANUAL/MOTORIZED STANDARD/AUTO-RETRACT/DIRECT RESPONSE Read this manual before installing or using this product. Failure to follow the instructions and safety precautions in this
More informationSolera Power Awning. Resources Required. Installation and Owner s Manual (For Aftermarket Application)
Solera Power Awning Solera Power Awning Installation and Owner s Manual (For Aftermarket Applications) Table of Contents Troubleshooting Manual Override Solera Power Awning Troubleshooting Solera Power
More informationExtend Retract All Awnings Awning 1. Single Awning. AC Fuse. Control Box #1 AC to Motor. Dual Awnings 4 - Awnings
Low Power On/Off Awning Control Extend Retract All Awnings Awning 1 Awning 2 Motion Sensor Stop High Low Power On/Off Awning Control Extend Retract All Awnings Awning 1 Awning 2 Motion Sensor Stop High
More informationBevel Buddy Instruction Manual
Bevel Buddy Instruction Manual We at Precision Sharpening Devices Inc. believe there are two very important steps in maximizing the savings this equipment can provide your company. First, use this manual
More informationINSTALLATION MANUAL ECLIPSE ARMS UPGRADE FOR ONE-TOUCH
RV INSTALLATION MANUAL ECLIPSE ARMS UPGRADE FOR ONE-TOUCH THIS PUBLICATION COVERS THE FOLLOWING MODELS: Universal Eclipse (8 foot extension) Eclipse XL (9 foot extension) These instructions apply to all
More informationFREEDOM RM AWNING. Product Overview... 1 Component Checklist... 2 Freedom RM Bracket Kits... 3
INSTALLATION MANUAL FREEDOM RM AWNING RV ROOF MOUNTED BOX AWNING TABLE OF CONTENTS Product Overview... 1 Component Checklist... 2 Freedom RM Bracket Kits... 3 Installation... 4 Bracket Installation...
More information0: ae
USA SERVICE OFFICE The Dometic Corp. 509 So. Poplar st. LaGrange, IN 46761 CANADA Dometic Dist 866 Langs Dr. Cambridge, Ontario CANADA N3H N7 0: ae 8000,8500&9000 @ Fabric Roller Tube Assembly with Universal
More informationBowDown. MiniMuM Crossbar spread 24 (61CM) Steel Hook (2X) Buckle Strap (2X) Plastic Tube (2X) Plain Strap (2X) SHORT BLACK T-BOLT (2x) BOWDOWN (2x)
BowDown MiniMuM Crossbar spread 24 (61CM) Heavy Duty strap (2x) SHORT BLACK T-BOLT (2x) BOWDOWN (2x) Bow Stern Tie Down Buckle Strap (2X) Plastic Tube (2X) Plain Strap (2X) Steel Hook (2X) IMPORTANT WARNING
More informationOtter Pro X-Over Lodge Installation and Set-Up Instructions
Otter Pro X-Over Lodge Installation and Set-Up Instructions Otter Pro X-Over Lodge Fits Magnum Otter II & Pro Sled Only Parts Identification and Check List MODEL NUMBERS: Complete Pkg Pro X-Over Lodge
More informationGas Go Anywhere /23/01
Gas Go Anywhere 55014 02/23/01 FOR OUTDOOR USE ONLY This grill does not include an LP fuel tank. Check Package Contents You should have received the parts listed below. While we give much attention to
More informationInstallation Guide. LPKPDR - Universal LP Conversion Kit for Professional & Designer Ranges/Rangetops. Viking Range, LLC.
Installation Guide Viking Range, LLC 111 Front Street Greenwood, Mississippi 38930 USA (662) 455-1200 For product information, call 1-888-845-4641 LPKPDR - Universal LP Conversion Kit for Professional
More informationThomas Scientific Swedesboro, NJ U.S.A.
Thomas Scientific Swedesboro, NJ 08085-0099 U.S.A. Wiley Laboratory Mill, Model 4 3375-E10 (115 V, 50/60 HZ) USE AND CARE OF CATALOG NUMBER: 3375-E10 Wiley Laboratory Mill, Model 4 (115 V, 50/60 HZ) UNPACKING
More informationInstructions for Installation and Operation
www.alekoproducts.com ALEKO Victoria Series Retractable Awning Instructions for Installation and Operation PLEASE DO NOT RETURN THIS PRODUCT TO THE STORE! The owner s manual includes assembly and operating
More informationINSTRUCTIONS INSTALLATION 9100 POWER CHANNEL AWNING LED TUBE AWNING
RECORD THIS INFORMATION FOR FUTURE REFERENCE: FRTA Model Number FRTA Serial Number Hardware Model Number Hardware Serial Number Date Purchased Retailer / Qualified Installer INSTALLATION INSTRUCTIONS 9100
More informationDIAMOND TECH INTERNATIONAL Innovations For Creativity DIAMOND LASER BAND SAW OPERATIONS MANUAL
SPEEDSTER-XL INSTRUCTION MANUAL DIAMOND TECH INTERNATIONAL Innovations For Creativity SPEEDSTER-XL DIAMOND LASER BAND SAW OPERATIONS MANUAL SPEEDSTER-XL INSTRUCTION MANUAL - PAGE 1 Before You Begin Read
More informationADDED PROTECTION FOR SLIDE-OUT ROOMS. Installation. Introduction... 2 Product Overview...2 Component Checklist...3
CAREFREE SIDEOUT KOVER II RV Installation ADDED PROTECTION FOR SLIDE-OUT ROOMS TABLE OF CONTENTS SOKII Shown with Full Case Option Introduction... 2 Product Overview...2 Component Checklist...3 Installation...
More informationPrimrose Awnings - Standard Manual Instructions
Primrose Awnings - Standard Manual Instructions Contents Warning 1.5m - 3.0m Awnings 4 x Expansion bolts (2 per bracket)** 2 x brackets 1 x Awning 1 x Winder handle 3.5m - 4m Awnings 6 x Expansion bolts
More informationPR-429BF-600M. Bell 429 Blade Fold Kit Operations Manual
Table of Contents Table of Contents... 1 Record of Revisions... 2 References... 3 Introduction... 4 Contact Information... 4 Prerequisites... 5 First Time Use... 6 Blade Clamp Placement... 6 Blade Clamp
More informationTCWS.38NG03.C BLACK DIAMOND BURNER KIT INSTRUCTIONS
IMPORTANT: THESE INSTRUCTIONS ARE TO REMAIN WITH THE HOMEOWNER These instructions are supplementary to the Installation and Operating Instructions supplied with the fireplace and should be kept together.
More informationOptional Controls (Depends which set was purchased) Set A (Remote control kit)
Primrose Awnings - Half Cassette Manual & Electric Instructions Contents Warning 1.5m - 3.0m Awnings 4 x Expansion bolts (2 per bracket)** 2 x brackets 1 x Awning 1 x Winder handle 3.5m - 4.0m Awnings
More informationINSTRUCTION SHEET TWISTLOCK VEHICLE STABILIZER (TVS) SYSTEM PN S: , ,
INSTRUCTION SHEET TWISTLOCK VEHICLE STABILIZER (TVS) SYSTEM PN S: 22-797010, 22-797020, 22-796161 COMPONENTS: 1. TVS-100, PN 22-797010: 47 60 (119 cm 152 cm) stroke TwistLock Vehicle Stabilizer. Component
More informationFREEDOM BUTTON KIT INSTALLATION GUIDE STEP 1
FREEDOM BUTTON KIT INSTALLATION GUIDE Installation of the Freedom Button kit is very simple and similar to the installation of a standard rear takedown pin and bolt catch latch. Before installing your
More information13401 Brooks Drive Baldwin Park, CA p f shademakerusa.com
13401 Brooks Drive Baldwin Park, CA 91706 p 626.338.8810 f 626.338.8816 info@shademakerusa.com shademakerusa.com 2018 Shademaker. All rights reserved. SMOM-POLARIS-1018 W A R R A N T Y : Upon receipt of
More informationHose Reel Series L701/G701
Hose Reel Series L70/G70.0 WARNING: Read carefully and understand all INSTRUCTIONS before operating. Failure to follow the safety rules and other basic safety precautions may result in serious personal
More informationAssembly instructions for Eurotramp trampolines Series: Ultimate, Grand Master Exclusiv, Grand Master, Master
Assembly instructions for Eurotramp trampolines Series: Ultimate, Grand Master Exclusiv, Grand Master, Master 1. Assembly instructions 2. Attaching the plastic coated steel cables on the Ultimate frame
More informationS P A OWNER'S MANUAL. Rev: Page 1 Solera Power Awning Owner's Manual
S P A OWNER'S MANUAL Rev: 09.16.2015 Page 1 Solera Power Awning Owner's Manual TABLE OF CONTENTS System Information 2 Operation 3 Extending The Awning 3 Retracting The Awning 3 Adjusting Pitch - All Solera
More informationInstallation & Operation Manual VHM Variable Height Series Arms with Fixed Angle Front End
3875 Cypress Drive Petaluma, CA 94954 800.228.2555 707.773.1100 Fax 707.773.1180 www.gcx.com Installation & Operation Manual VHM Variable Height Series Arms with Fixed Angle Front End Products covered
More informationThermostatic Griddle Field Service Kit Instructions
Thermostatic Griddle Field Service Kit Instructions The following document provides instructions on how to install a Garland Thermostatic Griddle Field Kit and is applicable to each 2 section of a Garland
More informationFREEDOM FREESTYLE WM
OWNER'S MANUAL FREEDOM FREESTYLE WM 12V Motorized Lateral Arm Box Awning RV with Direct Response Before operating the awning, carefully review the Owner's Manual. The manual contains important safety information,
More informationWITH DIRECT RESPONSE ELECTRONICS. Printed From. Introduction... 2
OWNER'S MANUAL APEX RV WITH DIRECT RESPONSE ELECTRONICS TABLE OF CONTENTS Introduction... 2 Operation... 2 Single Awning Control Panel... 3 Multiple Awning Control Panels... 4 The Auto- System... 5 Using
More informationRETRACTABLE AWNINGS OWNER S MANUAL & INSTALLATION INSTRUCTIONS. SunSetter. VISTA Awnings, Motorized Awnings and Motorized Pro Awnings
RETRACTABLE AWNINGS OWNER S MANUAL & INSTALLATION INSTRUCTIONS SunSetter VISTA Awnings, Motorized Awnings and Motorized Pro Awnings WARNING: Failure to follow these instructions could result in PERSONAL
More informationSPIRAL SLICER Instruction Manual Model #5280 & 5280M. Part No Revised Feb. 2010
SPIRAL SLICER Instruction Manual Model #5280 & 5280M Part No. 82876 Revised Feb. 2010 SAFETY PRECAUTIONS INSTALLATION INSTRUCTIONS Inspection of Shipment: 5280 & 5280M SPIRAL SLICER Unpack all cartons
More informationDeZURIK AM-SERIES MANUAL GEAR ACTUATOR USED ON BUTTERFLY VALVES
AM-SERIES MANUAL GEAR ACTUATOR USED ON BUTTERFLY VALVES Instruction D10501 January 2015 Instructions These instructions provide information about AM-Series Manual Actuators used on Butterfly Valves. They
More information